Bakers Pride Oven MT-200 service manual Routine Maintenance

Page 13

Convection Oven

Maintenance

 

 

Maintenance

Failure to comply with the maintenance below could result in a serious accident.

Electrocution, equipment failure or property damage could result if an unlicensed electrician performs electrical repair. Ensure that a licensed electrician performs electrical repair.

Routine Maintenance

Before performing maintenance, unplug the oven.

During cleaning, use protective gloves, mask and garments as required by standards.

At the end of each workday clean the inside of the oven with appropriate convection ovens following the suggestions of your supplier. Do not use corrosive or acidic convection ovens, or convection ovens which are not suitable for this type of cleaning.

To make cleaning easier, remove the lateral diffusers by lifting them slightly so they are free of the holding pegs.

Clean the stainless steel parts daily with lukewarm soapy water, and rinse thoroughly. Then dry.

Absolutely do not clean the stainless steel with steel wool or common steel brushes, since they may leave ferrous particles which may oxidize, thus causing rust spots.

Stainless steel wool can be used in the direction of the satin finish.

If the oven is not used for long periods, use a cotton ball to lay a coat of petroleum jelly on all surfaces; also regularly ventilate the rooms.

11

Image 13
Contents Convection Oven Limited ONE Year Warranty Warranty InformationTable of Contents Safety Signs and Messages Safety PrecautionsIntroduction Technical Data Power Supply Terminal BoardSafety Standards Data PlateOperation Controls and IndicatorsGeneral Instructions for Use Start-Up and Use Switching OffSafety Standards InstallationEnvironmental Standards Transport and UnpackingInstallation Instructions Electrical Connections Convection Oven Installation Oven Chamber Safety Thermostat Automatic Safety and Control Devices of the OvenProtection of the Auxiliary Electrical Circuit Protection of the Chamber FanRoutine Maintenance MaintenanceOven Chamber Cleaning Cleaning the Fan Cleaning the Door GlassProblem Probable Remedy Cause TroubleshootingReplacement of Motors Repair ProceduresBulb, Heating Element and Motor Fan Outer Coverings30W Motor Heating ElementsElectro-Mechanical Controls Replacement of Chamber Light and Glass GasketChamber Face Gasket Replacement Parts POS Code BKI # Description Wiring Diagrams Convection Oven Box 80400, Simpsonville, S.C -0400, USA LI0131/0808