Craftsman 107.27768 manual Electrical Group ZTS 7500, HeadlightSwitch Seatpan Optional

Page 78

Electrical

Group (986808_986894)

ZTS 7500 - 107.27768

NOTE: Unless noted otherwise,

use the standard hardware torque specification chart.

16

		Seat	15
		Switch
		/
		13
					/
				,/
		12		/
		12
2				_	19
2		--	31	'	20
				\
			Clip harnessto	',_
HeadlightSwitch			Clip harnessto		,
HeadlightSwitch			seatpan,
(Optional)---_.	10		seatpan,
(Optional)---_.	10
	Tie Harness	3O
	to throttle	3O

cable

1 /

Headlight

Electric (Optional)

Clutch

21

/

/

/

To Engine

18 Block

TOStarterBolt on Engine

35

34

33

_ Tie cables

10

"_ ,_._trep

y l ", /

24

25

27

28

29

23

/

TOEngine

PTS - 14

Image 78

Contents Operators Manual Service IdentificationInside Back General Operation Ignition System Service and Maintenance Safety & Operation Decals Height AdjustmentRotating Blades \,CRAFTSMAN Setup instructions Two Bin Bagger Headlight Kit Front Bumper KitRead The Operators Control Functions PTO Switch General Operating SafetyIgnition Switch Hour MeterChecks Before Starting Fuel RecommendationsDo not stop or park rider over dry leaves, grass or Starting the Engine Emergency StoppingStopping the Rider & Engine MowingForward Travel Practice Forward TravelSmooth Travel Levers GraduallyExecuting an End=Of=Row Zero Turn Practice Turning Around a CornerExecuting Turns Turning In Place Practice Turning in PlaceMower Deck Removal Installation Installing the Mower DeckRemoving the Mower Deck Models Maintenance ScheduleAll 19HP Briggs & StrattonChecktire Pressure Clean Debris from Rider and Engine CompartmentClean Debris from Engine Cooling Areas and AIR Filter PressureService Interval 25 hours Arbor Lubrication 3-Blade Model ShownClean Deck Check / Replace Mower Blades Blade Removal WorkbenchOperational Safety Checks Cleaning the Battery and CablesCheck Rider Safety System Service interval 100 HoursAdjustment Window Qty , one shown B. Adjustment Nut Check / Adjust PTO ClutchService interval 200 Hours Adjustment NutCheck Engine OIL Level Change Engine OILChange Engine OIL & Filter AiR Filter & PRE-CLEANER Air Filter Latch Air Filter CoverAir Filter Service Pre=Cleaner ServiceReplace Spark Plug Adjustment Speed Balancing AdjustmentGround Speed Control Lever Brake Adjustment Cutting Height AdjustmentPTO Clutch Adjustment Battery ChargingMower Deck Leveling Adjustments Side to Side LevelingMower Belt Replacement Front To Back LevelingBackside idler Pulley STO RAG E Troubleshooting Rider Rider will not TroubleshootingMower Mower cut isZTS Hardware Garantja Limitada DEL Equipo Montable DE CraftsmanTransporte Y Almacenamento Operacion EN Cuestas Equipo RElVlOLCADO Unidades MontaSERViCiO Y MANTENilVllENTO Interruptor Calcomania Peligro/Advertencia, inferiorIdentificaci6n Recolector de Hierba con Bolsa Gemela Faro delantero 2s uMOperador FrescaPalancas de velocidad en suelo Freno de paradaAhogador Interruptor PTO Interruptor de EncendidoMedidor de Horas Ajuste de AJtura de Corte de PodadoraAdvertencia Reiviolques Nunca permita que pasajeros se paseen en la unidadMotor Como Arrancar EL MotorManualmente Lemas PR. ,CTICA DE IvianejoTraslado sin prob= Manejo Hacia Manejo en AdelanteVuelta en el Mismo Lugar Prbctica de dar Vuelta en una EsquinaEjecutar un Giro Cero al Final de la Fila Prctica de Vuelta en el LugarInstalar la Cubierta de la Podadora Remocion E Instalacion DE LA Cubierta DE LA PodadoraQuitar la Cubierta de la Podadora Instalar o quitar la podadoraPrograma DEL MONTABLE, de todos Los Antes deAnual TRO DE AIREA. Rejilla de Admisi6n Intervalo de Servicio 25 horasLUBRICACI6N AceitePara su seguridad personal, los tornillos de OperacionIntervalo de Servicio 200 horas Si la unidad no pasa una prueba de seguridadVERIFICAR/AJUSTAR Embrague DEL PTO Verifique EL Nivel DE Aceite DEL Motor SERVlCIO DEL Filtro DE Airey DEL PRE Remoci6n e instalaci6n del filtro de airePredepurador Reemplace LA BUJiA DE Encendido = Servicio del prepurificadorServicio del filtro de aire Prepurificador Filtro de aireAjuste DE Palanca DE Control DE VelocidadPernos de Montaje Perilla Ajuste DEL Freno Ajuste DE LA Altura DE CorteAjuste DEL Embrague DEL PTO Ajustes DEL MotorAjuste DE Nivel DE LA Cubierta DE LA Podadora Nivelado de un Lado a OttoTuerca Exterior Nivelado de Adelante hacia Atrs Polea Derecha del Arbol de SujecJ6nAdvertencia Diagn6stico Del TractorConsumo de Diagn6stico de la Podadora RepairParts Frame, Body & Seat Group ZTS 7500Frame Body & Seat Group ZTSFootnotes PTS-4 Frame, Body & Seat Group ZTS REF no Part NO. QTY. DescriptionUtch Engine Group 19HP Briggs & Stratton ZTS 7500Engine Group 19HP Briggs Stratton 987321 REF noCarrier & Transmission Group ZTS 7500 1618Frame Assembly Carrier Transmission Group 987362Carrier & Transmission Group ZTS 7500 Carrier Transmission Group Refno Partno QTY DescriptionControls Group ZTS 7500Controls Group 986806 Refno QTY DescriptionHeadlightSwitch Seatpan Optional Electrical Group ZTS 7500Electrical Group QTY DescriptionTorque to 44 55 ft. Ibs Or 59.4 74.8 Nm PTS-16 REF no QTY Description Decals Group D987352 987357987358986884986857987350 ZTS 7500 Decals Group D987352 987357987358986884986857987350 QTY DescriptionMower Deck Clutch & Support Group Mower Deck Clutch Support Group No Part no QTY DescriptionMower Deck Height Adjustment Group ZTS 7500 Mower Deck Height Adjustment Group 987324 Mower Deck Housing, Arbors & Blades Group ZTS 7500 Mower Deck Housing Arbors Blades Group 987322 221 13J 868@1266A Engine Parts Part DescriptionBriggs & Stratton Engine Parts ZTS 7500 = Model No Hardware identification& TorqueSpecifications PTS Acuerdo de Protecci6n de Reparaciones Sears Installation ServiceRepair Protection Agreements Servicio de Jnstalaci6n de SearsCall anytime, day or night U.S.A. and Canada Call anytime, day or night U.S.A. only