Sears 917.275223 Cause, Cutting too much grass/too fast Throttle in Choke position, Correction

Page 35

TROUBLESHOOTINGCHART

PROBLEM

Loss of power

Excessive vibration

Engine contln ues to run when

operator leaves seat with attachment

clutch engaged

Poorcut-uneven

CAUSE

1, Cutting too much grass/too fast.

2, Throttle in "CHOKE" position.

3.Build-up of grass, leaves and trash under mower.

4, Dirty air filter,

5.Low oil level/dirty oil. 6, Faulty spark plug.

7.Dirty fuel filter.

8.Stale or dirtyfuel.

9.Water in fuel.

10.Spark plug wire loose,

11.Dirty engine air screen/fins.

12.Dirty/clogged muffler.

13.Loose or damaged widng.

14.Carburetor out of adjustment,

15, Engine valves out of adjustment.

1, Worn, bent or loose blade,

2.Bent blade mandrel.

3.Loose/damaged part(s),

1.Faulty operator-safety presence control system.

1.Wom. bent or loose blade.

2.Mower deck not level.

3.Buildup of grass, leaves, and trash under mower.

4.Bent blade mandrel.

5.Clogged mower deck vent from build-up of grass, leaves, and trash around mandrels,

CORRECTION

1, Set in _Higher Cut" position reduce speed.

2.Adjust throttlecontrol,

3.Clean underside of mower

housing.

4, Clean/replace air filter.

5.Check oil level/change oil.

6.Clean and regap or change spark plug.

7.Replace fuel filter.

8.Drain fuel tank and refill with fresh gasoline,

9.Drain fuel tank and carburetor, refill tank with

fresh gasoline and replace fuel filter,

10.Connect and tighten spark plug wire.

11.Clean engine air screen/ fins.

12.Clean/replace muffler. 13.Check all widng.

14. See "To Adjust Carburetor" in Service Adjustments section.

15.Contact a Sears or other qualified service center.

1.Replace blade. Tighten blade bolt.

2.Replace blade mandrel,

3.Tighten loose part(s). Replace damaged parts.

1, Check widng, switches and connections,If notcorrected

contact a Sears or other qualified service center.

1.Replace blade, Tighten blade belt.

2.Level mower deck.

3.Clean underside of mower housing.

4.Replace blade mandrel,

5.Clean around mandrels to open vent holes.

35

Page 34 Page 36
Image 35
Page 34 Page 36
Contents Garden Tractor Limited 90 DAY Warranty on Battery I1. Slope Operation General OperationMow only in daylight or good artificial light StorageMachine. Tall grass can hide obstacles IV. ServiceCancer and birth defects or other repro- ductive harm Repair Agreement Gasoline 3.5 GallonsAndtype Regular Speedmph ReverseWashers X 3/4 x 14 Ga Steedng Sleeve SteedngWheellnse17132 x 1-3/16 x 12 Gauge Retainer Shoulder BoltVideo Cassee Keys Slope Sheet Teenng Steering Wheel Adapter Sleeve Tabs Extension Tools Required for AssemblyTo Removetractor from Carton Unpack Carton Before Removing Tractor from Skid Attach Steering WheelBolt Howto SET Upyourtractor Check BatteryInstall Seat Slide mower under tractor with Assemble Gaugewheelsto Mower DeckCheck for Proper Position of ALL Belts Check Tire PressureCheck Mower Levelness Damped Charged, Minimum 1 hour at 6 ampsENG,NEONENO,NEOFF.LRESSUREL,OHTSOND.P T Lift Attachment Clutch SwitchKnowyourtractor Ground Drive To Adjust Mower Cutting HeightHowto Useyourtractor To SET Parking Brake StoppingTo Operate on Hills To Adjust Gauge WheelsTo Operate Mower Deflector ShieldADD Gasoline To TransportTowing Carts and Other ATTACH- Ments Before Starting the Engine Check Engine OIL LevelAutomatictransmission Warm UP Tion of clippings and more uniform cutting Before Each USE Lubrication ChartGeneral Recommendations Operator Presence System TractorBrake Operation TiresTransaxle Pump Fluid To Clean Battery and TerminalsBelts Transaxle CoolingTo Service Cartridge Clean AIR ScreenClean AIR Intakeicooling Areas To Service PRE-CLEANERRactor To Remove Mower To Install MowerTo Level Mower Housing SIDE-TO-SIDE AdjustmentTo Replace Mower Drive Belt Mower Drive Belt Removal FRONT-TO-BACK AdjustmentMower Drive Belt Installation To Replace Mower Blade Drive Belt Electric ClutchTo Replace Motion Drive Belt To Adjust Attachment ClutchBelt Installation Transaxle Motion Control Lever Neutral AdjustmentBattery To Adjust Steering Wheel ALIGN- MentFront Wheel TOE-IN Adjustment To Adjust TOE-INTo Replace Headlight Bulb To Adjust Attachment Lift SpringTo Remove Hood and Grill Assembly To Replace FusePreliminary Setting To Adjust Throttle Control CableTo Adjust Carburetor To Adjust Choke ControlRecheck idle speed. Readjust if necessary Adjusting screw in or out until correct idle is attainedCyunders 1RACTOREngine Fuel System Engine OILProblem Troubleshooting ChartCorrection CauseCutting too much grass/too fast Throttle in Choke position Wom. bent or loose blade Mower deck not levelOFF Troubleshooting Chart Problem Cause CorrectionFaulty alternator Freewheel control in disengaged position Wet grass Mower deck not levelTRACTOR- Model Number Schematic Electrical TRACTORMODELNUMBER917-.275223 TRACTORMODELNUMBER917-.275223 Electrical TRACTOR- MODELNUMBER917.275223 Chassisandenclosures TRACTORMODELNUMBER917-.275223 Chassisandenclosures TRACTOR- MODELNUMBER917.275223 Grounddrive KEY Part NO. NO.DESCRIPTION TRACTOR- Model Number Steering KEY pART TRACTORMODELNUMBER917-.275223 Engine TRACTOR- Model Number Seatassembly TRACTORMODELNUMBER917-.275223 Decals TRACTOR- MODELNUMBER917.275223 LiFTASSEMBLY Ili TRACTOR- Model NU Mber Mowerdeck TRACTOR- MODELNUMBER917.275223 TRANSAXLE-MODELNUMBER311.3500 Screw Cylinder Head Valvi & Breather EADNALVE/BREATHER KEY IiI 24-164-06-S ECONTROLSp KEY Part NO. NO.DESCRIPTION Crankshaft Exhaust J Fuel System Not Illustrated Page Suggested Guide for Sighting Slopes for Safe Operation 0o..-7278 Part

917.275223 specifications

The Sears 917.275223 is a robust lawn tractor that has earned a reputation among homeowners for its reliable performance and durability. Designed primarily for residential use, this lawn tractor features a user-friendly design that caters to both seasoned gardeners and those new to lawn care.

One of the standout characteristics of the Sears 917.275223 is its powerful engine, typically a Briggs & Stratton engine that delivers the necessary torque to tackle tough mowing conditions. This engine is known for its reliability and ease of starting, ensuring that homeowners can quickly get to work without frustration. Paired with a smooth-cutting deck, the tractor can efficiently handle various grass types and terrains with ease.

The cutting deck, often sized at 42 inches, provides a wide swath, allowing users to cover substantial ground in less time. Equipped with adjustable cutting heights, the Sears 917.275223 ensures a customizable mowing experience, which is beneficial for maintaining a healthy lawn. The ease of adjustment means users can switch between different grass and lawn types without hassle.

In terms of technology, the Sears 917.275223 often features a hydrostatic transmission. This technology allows for seamless speed adjustments without the need for manual gear changes, which is particularly advantageous when navigating uneven terrain or around landscaping features. The ease of steering is complemented by comfortable controls, putting everything within easy reach for the operator.

Another notable feature of this tractor is its ergonomic design. The seat is designed for comfort during longer mowing sessions, while the overall layout promotes ease of use. The placement of the foot pedals and steering wheel ensures that operators can maneuver and control the vehicle effortlessly.

The Sears 917.275223 is also designed with durability in mind. Constructed with high-quality materials, it can withstand the rigors of frequent lawn care tasks. Additionally, maintenance is simplified for the user, with easily accessible components for oil changes, belt adjustments, and other routine tasks.

In summary, the Sears 917.275223 lawn tractor combines a powerful engine, user-friendly technology, adjustable cutting options, and durable construction, making it a favorite among homeowners looking to maintain their lawns efficiently. With its thoughtful design and reliable performance, it stands as an excellent choice for both novice and experienced users alike.
Top Page Image Contents