Sears 917.275223 owner manual KEY pART

Page 45

TRACTOR- MODEL NUMBER 917.275223

STEERING

KEY pART

NO. NO.DESCRIPTION

1159944X428 Wheel, Steering

2178557 Axle Asrn., Front

36855M Fitting, Grease

4 161849 Spindle Asm, LH

5 161848 Sp_n@eAs_, P,H

66266H Beadng, Race Thrust Harden

7121748)( Washer 25132 x 1-5/8 x 16 Ga.

812000029 Ring, Klip#T5304-75

9 121232X Cap, Spindle

1074781044 Bolt, Fin Hex 5/8-11x 2-3/4

11136518 Spacer Bearing Axle FrOnt

1273901000 Nut, Lock Flange 5/8-11Unc

13121749X Washer 25/32 x 1-'t/4x 16 Ga.

14STD551137 Wastler, LockHvyHIclSpr 3/8

15$1D541537 Nut, Lock Center 3/_-24 UNF

161454,03 _,ha_t Astn., S,_eer_ng

17	137347	Rod Asrn., Tie Ball J Ball Vgt (INC. Key NO. 36-40)
18	175572	Dragllnk Vgt

191560_1 Support Asm., Steering Vgt

20 163887)(428 Boot, Steering

21 159945 Adapter, Wlteel Steering

22 155105 Bushing, Strg. BIk

23 152927 Screw

2574780616 Bolt, Fin Hex 3/8-16 x 1 Gr. 5

26159946X428 Cap, Wheel Steering

273366R Beadng, CoL Strg.

281700_6_2 _ctew, 3/8-1_ x 3/4

29104239)( Beadng, Flange

31	138136	Bushing, Nyllner Snap
32	19111610	Washer 11/32 x 1 x 10 Ga.

33STD551131 Washer, Lock Hvy Hid Spr 5111_

3474780512 Boit Fin Hex 5/16-18unc x 3/4

35	138059	Gear, Sector Steering
36	137156	Tie Rod

3773360600 Jam Nut RH Thread

38109850X Joint Asm. Ball RH Thread

3973700600 Jam Nut LH Thread

4010cJ851X 3olnl Asm. Ba_ LI-_Thresd

41155246 Braoket Switch Interlock VGT 97

4217490508 Screw Thdrol 5/16-18x 1/2 Tyt

44160135X428 Extension, Steering

451913241_ Washer 13/32 x 1-1/20 x 1'1Ga.

46178291 Spacer .407 x .625 x .500

47177863 Bracket Asm Idler Stationary

4817060612 Screw 3/8-16 x .75

49131494 Pulley Idler Flat

5073900600 Nut Lock Fig 3/8-16 UNC

NOTE: All componen_ dirnens_ns 9_ven In U. S. inches 1 inch = 25.4 mm

45

Image 45

Contents

Garden Tractor Limited 90 DAY Warranty on Battery Mow only in daylight or good artificial light General OperationStorage I1. Slope OperationMachine. Tall grass can hide obstacles IV. ServiceCancer and birth defects or other repro- ductive harm Andtype Regular Gasoline 3.5 GallonsSpeedmph Reverse Repair Agreement17132 x 1-3/16 x 12 Gauge Steedng Sleeve SteedngWheellnseRetainer Shoulder Bolt Washers X 3/4 x 14 GaVideo Cassee Keys Slope Sheet To Removetractor from Carton Unpack Carton Tools Required for AssemblyBefore Removing Tractor from Skid Attach Steering Wheel Teenng Steering Wheel Adapter Sleeve Tabs ExtensionHowto SET Upyourtractor Check Battery Install SeatBolt Slide mower under tractor with Assemble Gaugewheelsto Mower DeckCheck Tire Pressure Check Mower LevelnessCheck for Proper Position of ALL Belts Damped Charged, Minimum 1 hour at 6 ampsENG,NEONENO,NEOFF.LRESSUREL,OHTSOND.P T Attachment Clutch Switch KnowyourtractorLift Howto Useyourtractor To SET Parking Brake To Adjust Mower Cutting HeightStopping Ground DriveTo Operate Mower To Adjust Gauge WheelsDeflector Shield To Operate on HillsTowing Carts and Other ATTACH- Ments To TransportBefore Starting the Engine Check Engine OIL Level ADD GasolineAutomatictransmission Warm UP Tion of clippings and more uniform cutting Lubrication Chart General RecommendationsBefore Each USE Brake Operation TractorTires Operator Presence SystemBelts To Clean Battery and TerminalsTransaxle Cooling Transaxle Pump FluidClean AIR Intakeicooling Areas Clean AIR ScreenTo Service PRE-CLEANER To Service CartridgeTo Level Mower Housing To Install MowerSIDE-TO-SIDE Adjustment Ractor To Remove MowerFRONT-TO-BACK Adjustment Mower Drive Belt InstallationTo Replace Mower Drive Belt Mower Drive Belt Removal To Replace Mower Blade Drive Belt Electric ClutchBelt Installation To Adjust Attachment ClutchTransaxle Motion Control Lever Neutral Adjustment To Replace Motion Drive BeltFront Wheel TOE-IN Adjustment To Adjust Steering Wheel ALIGN- MentTo Adjust TOE-IN BatteryTo Remove Hood and Grill Assembly To Adjust Attachment Lift SpringTo Replace Fuse To Replace Headlight BulbTo Adjust Carburetor To Adjust Throttle Control CableTo Adjust Choke Control Preliminary SettingRecheck idle speed. Readjust if necessary Adjusting screw in or out until correct idle is attainedEngine Fuel System 1RACTOREngine OIL CyundersProblem Troubleshooting ChartCutting too much grass/too fast Throttle in Choke position CauseWom. bent or loose blade Mower deck not level CorrectionFaulty alternator Freewheel control in disengaged position Troubleshooting Chart Problem Cause CorrectionWet grass Mower deck not level OFFTRACTOR- Model Number Schematic Electrical TRACTORMODELNUMBER917-.275223 TRACTORMODELNUMBER917-.275223 Electrical TRACTOR- MODELNUMBER917.275223 Chassisandenclosures TRACTORMODELNUMBER917-.275223 Chassisandenclosures TRACTOR- MODELNUMBER917.275223 Grounddrive KEY Part NO. NO.DESCRIPTION TRACTOR- Model Number Steering KEY pART TRACTORMODELNUMBER917-.275223 Engine TRACTOR- Model Number Seatassembly TRACTORMODELNUMBER917-.275223 Decals TRACTOR- MODELNUMBER917.275223 LiFTASSEMBLY Ili TRACTOR- Model NU Mber Mowerdeck TRACTOR- MODELNUMBER917.275223 TRANSAXLE-MODELNUMBER311.3500 Screw Cylinder Head Valvi & Breather EADNALVE/BREATHER KEY IiI 24-164-06-S ECONTROLSp KEY Part NO. NO.DESCRIPTION Crankshaft Exhaust J Fuel System Not Illustrated Page Suggested Guide for Sighting Slopes for Safe Operation 0o..-7278 Part