Sears 917.257462 Engine, AIR Filter See Fig, To Clean Battery and Terminals, Transaxle Cooling

Page 16

MAINTENANCE

TO CLEAN BATTERY AND TERMINALS -

Corrosion and dirt on the battery and terminals can cause the battery to "leak" power.

•Remove terminal guard.

•Disconnect BLACK battery cable first then RED bat- tery cable and remove battery from tractor.

•Wash battery with solution of four tablespoons of baking sodatoone gallon of water. Becareful notto get the soda solution into the cells.

•Rinse the battery with plain water and dry.

•Clean terminals and battery cable ends with wire brush until bright.

•Coat terminals with grease or petroleum jelly.

•Reinstall battery (See "INSTALL BA]-I-ERY" in the Assembly section of this manual).

V- BELTS

Check V-Belts for deterioration and wear after 100 hours. Replace if necessary. The belts are not adjustable. Re- place belts if they begin to slip from wear.

TRANSAXLE COOLING

Keep transaxle free from build-up of dirt and chaff which can restrict cooling.

ENGINE

LUBRICATION

Change the oil after the first two hours of operation and every 25 hours thereafter or at least once a year if the tractor is not used for 25 hours in one year.

Check the crankcase oil level before starting the engine and after each eight (8) hours of continuous use. Add SAE

30W motor oil or equalivent. Tighten oil fill cap/dipstick securely each time you check the oil level. SAE 5W-30 motor oil may be used to make starting easier in areas where temperature is consistently 32 ° F or lower.

TO CHANGE ENGINE OIL (See Fig. 16 and 17)-

Determine temperature range expected before oil change. All oil must meet API service classification SG.

•Be sure vehicle is on level surface.

•Oil will drain more freely when warm.

•Catch oil in a suitable container.

•Remove oil fill dipstick. Be careful not to allow dirt to enter the engine when changing oil.

•Remove drain plug.

•After oil has drained completely, replace oil drain plug and tighten securely.

•Refill engine with oil through oil fill dipstick tube. Pour

slowly. Do not overfill. For approximate capacity see Product Specifications on page 3 of this manual.

•Use gauge on oil fill dipstick for checking level. Be sure dipstick cap is tightened securely for accurate reading. Keep oil at "FULL" line on dipstick.

RECOMMENDED SAE VISCOSITY GRADES

-20°

0°

32"

60°

80 °

100°

OIL FILL

DIPSTICK

FIG. 16

OIL DRAIN

PLUG

TO REMOVE

FIG. 17

AIR FILTER (See Fig. 18)

Your engine will not run properly and may be damaged by using a dirty air filter. Remove cartridge every 25 hours and tap gently to clean. Replace paper cartridge once a year or after every 100 hours of operation, more often if used in very dusty, dirty conditions.

•Remove knob and cover.

•Remove cartridge nut and clean or replace cartridge.

•Reassemble and tighten securely.

NOTE: Do not attempt to clean or oil the paper cartridge.

COVER KNOB

COVER _

CARTRIDGE

CARTRIDGE

I

FIG, 18

16

Page 15 Page 17
Image 16
Page 15 Page 17
Contents Sears HP Electric Start 36 Mower Speed Lawn RiderSafety is Involved Safe Operation Practices for Ride-On MowersII. Slope Operation III. ChildrenProduct Specifications Full 90 DAY Warranty on BatteryMaintenance Agreement Customer ResponsibilitiesMaintenance EnginePerformance Sparkplug Muffler AIR Filter Stabilizer Blades BeltsTable of Contents Contents of Hardware Pack Tools Required for Assembly To Remove Unit from CartonBefore Rolling Unit OFF Skid Unpack CartonAssembly HOW to SET UP Your TractorChecklist All assembly instructions have been completedOperation Know Your Lawn RiderTo USE Throttle Control See Fig To Move Forward and BackwardSee Figs To SET Parking Brake See FigTo Adjust Mower Cutting Height Before Starting the EngineTo Operate Mower See Figs To TransportMowing Tips Important When Operating in TemperaturesADD Gasoline Maintenance Lubrication ChartGeneral Recommendations Before Each USELawn Rider Blade CareBlade Removal See Fig Brake OperationTo Clean Battery and Terminals EngineAIR Filter See Fig Transaxle CoolingCleaning AIR Screen See FigMuffler Spark PlugsTo Install Mower See Fig Mower Upstop Adjustment See FigLawn Rider To Remove Mower See FigTo Level Mower Housing See Fig Service and AdjustmentsViewed from Front of Tractor To Adjust Brake See Fig To Adjust Steering Wheel AlignmentKeeper To Replace Motion Drive Belt See FigTo Start Engine with a Weak Battery See Fig To Remove Hood See FIGTo Remove Wheel for Repairs See Fig To Replace FuseTo Adjust Carburetor See Fig To Adjust Throttle Control CablePreliminary Setting EngineBattery OtherTractor Fuel SystemTroubleshooting Points Problem Cause CorrectionProblem Cause CorrectionSchematic Wheels Tires DecalsKEY Part Description NO. no USAElectrical KEY Part Description ElectricalStandard Hardware - Purchase Locally UNC HoodStandard Hardware - Purchase Locally 129965 Case, Battery Fender / ChassisFrame 19132012 WasherSeat Locknut, Hex, Larg, FlangeDash 1011Standard Hardware Purchase Locally KEY Part NO. no Description Steering WheelLower, Steering Link, Drag Sector Gear / Axle SupportBolt, Hex Front Axle Cap, Spindle25/32 x 1-5/8 x 16 Gauge Standard Hardware Purchase LocallyBrake / Rear Mower Lift Assembly KEY122504X Hardware Shown LargerEngine / Throttle Standard Hardware PurchaseGround Drive Keeper, Ground Drive Belt, IdlerArm, Ground Drive Clutch Idler, FlatTransaxle 2530Pulley Mower Lift Lever Clip, Fuel Line106932X STD560907Mower Deck Mower Deck FOOTE/DANA Transaxle Model Number 2631 2732FOOTE/DANA TRANSAXLE- Model Number Briggs & Stratton Engine Model Number 283707, Type Number 2653O7 219 42266S 224 138 44542.1 310 801490450 399265 Bearing, Cylinder Requires Special 22406193805 391086Mounting 635 66538224546 Sight and Hold this Level with SKY Line or Tree Sighting Guide Only Ride UP and Down HILL, not Across HillMAX Model Number 917,257462 HOW to Order Repair Parts19.91

917.257462 specifications

The Sears 917.257462 is a well-known lawn tractor that has earned a reputation for its reliable performance and robust build. Designed for homeowners with medium to large yards, this model combines functionality and ease of use, making it an excellent choice for both novice and experienced gardeners.

One of the standout features of the Sears 917.257462 is its powerful engine. Equipped with a reliable, air-cooled, four-stroke engine, it offers ample horsepower to handle various mowing tasks. The engine's efficient design ensures that it provides consistent power while maintaining fuel economy, allowing owners to tackle extensive lawn areas without frequent refueling.

The cutting system of the Sears 917.257462 is designed for efficiency and versatility. It boasts a durable, reinforced mowing deck that allows for multiple cutting heights, accommodating different grass types and lawn conditions. This adaptability makes it easy to achieve a clean, even cut, regardless of the lawn's terrain. Additionally, the tractor features a bagging system that aids in collecting grass clippings for a tidy finish.

Ergonomics play a crucial role in the design of the Sears 917.257462. The operator's seat is adjustable, providing comfort and promoting good posture during extended use. The steering system is responsive, facilitating easy maneuverability around obstacles in the yard. The controls are intuitively placed, making it simple for users to operate the tractor while focusing on the task at hand.

Another key characteristic of this tractor is its durability. Constructed with high-quality materials, the Sears 917.257462 is built to withstand the rigors of regular use. Its robust frame and fortified components contribute to its longevity, minimizing the need for frequent repairs or replacements.

Furthermore, the tractor’s maintenance requirements are straightforward. Users will find that routine upkeep is manageable, thanks to accessible engine compartments and clear instructions for oil changes and blade sharpening. This ease of maintenance not only saves time but also contributes to the tractor's overall longevity.

In summary, the Sears 917.257462 is a formidable lawn tractor that combines a powerful engine, versatile cutting capabilities, ergonomic design, and durable construction. Its user-friendly features, coupled with low maintenance requirements, make it an ideal choice for those looking to maintain their lawns with efficiency and ease. Whether grooming a small yard or tackling larger landscapes, this model remains a reliable partner in lawn care.
Top Page Image Contents