Sears 917.257462 manual Troubleshooting Points, Problem Cause Correction

Page 24

TROUBLESHOOTING POINTS

PROBLEM

CAUSE

CORRECTION

Will not start

Hard to start

Engine will not turn over

Engine clicks but will not start

Loss of power

1.Out offuel.

2.Enginenot"CHOKED"properly.

3.Engineflooded.

4.Bad sparkplug.

5.Dirtyair filter.

6.Dirtyfuel filter.

7.Water In fuel.

8.Looseor damagedwiring.

9.Carburetoroutof adjustment.

10.Enginevalves outof adjustment.

1.Dirtyair filter.

2.Bad sparkplug.

3.Weak or dead battery.

4.Dirtyfuel filter.

5.Stale or dirtyfuel,

6.Looseor damagedwiring.

7.Carburetoroutof adjustment.

8.Enginevalvesout of adjustment.

1.Clutch/brakepedal not depressed.

2.Attachmentclutchis engaged.

3.Sparkplugwire is disconnected.

4.Weak or dead battery.

5.Blownfuse.

6.Corrodedbatteryterminals.

7.Looseor damaged wiring.

8.Faultyignitionswitch.

9.Faultysolenoidor starter.

"10. Faultyoperatorpresenceswitch(es).

1.Weak or dead battery.

2.Corrodedbatteryterminals.

3.Looseor damagedwiring.

4.Faultysolenoidor starter.

1.Cutting too much grass/too fast.

2.Throttle in "CHOKE" position.

3.Build-up of grass, leaves and trash under mower.

4.Dirty air filter.

5.Low oillevel/dirtyoil.

6.Faultysparkplug,

7.Dirtyfuel filter.

8.Stale or dirtyfuel.

9.Water in fuel.

10.Sparkplugwire loose.

11.Dirtyengineair screen/fins.

12.Dirty/cloggedmuffler.

13.Looseor damaged wiring,

14.Carburetorout of adjustment.

15.Enginevalvesoutof adjustment.

I.RIIfuel tank.

2.See "TO START ENGINE" In the Operationsection.

3.Wait severalminutesbeforeattemptingto start.

4.Replacesparkplug.

5.Clean/replaceair filter,

6.Replacefuel filter.

7.Drainfuel tank andcarburetor,refilltankwithfresh gasolineand replacefuel filter.

8.Check all wiring.

9.ContactSears ServiceCenter/Department.

10.ContactSears ServiceCenter/Department.

1.Clean/replaceair filter.

2.Replacesparkplug.

3.Rechargeor replace battery.

4.Replacefuel filter.

5.Drainfuel tankand refillwithfresh gasoline.

6.Checkall wiring.

7.ContactSears ServiceCenter/Department.

8.ContactSears ServiceCenter/Department.

t.Depressclutch/brakepedal.

2.Disengageattachmentclutch,

3.Connectwire to sparkplug.

4.Rechargeor replacebattery.

5.Replacefuse.

6.Clean batteryterminals.

7, Check all wiring.

8.Check/replaceignitionswitch.

9.Check/replacesolenoidor starter.

10.ContactSears ServiceCenter/Department.

1.Rechargeor replace battery. 2, Clean batteryterminals.

3.Check all wiring.

4.Check/replacesolenoidor starter.

1.Set in "Higher Cut"position/reducespeed.

2.Adjustthrottlecontrol.

3.Clean undersideof mowerhousing.

4.Clean/replaceairfilter.

5.Check oillevel/changeoil.

6.Clean and regapor changesparkplug.

7.Replacefuel filter.

8; Drainfuel tank and refillwithfresh gasoline.

9.Drainfuel tank and carburetor, refilltank withfresh gasolineand replacefuel filter.

10.Connect andtightensparkplugwire.

11.Clean engineair screen/fins.

12.Clean/replacemuffler.

13.Checkall wiring.

14.ContactSears ServiceCenter/Department.

15.ContactSears ServiceCenter/Department.

Excessive vibration

1.

Worn, bent or loose blade.

 

2.

Bentblade mandrel.

 

3.

Loose/damagedpart(s).

1.Replace blade. Tighten blade bolt.

2.Replace blade mandrel.

3.Tighten loose part(s). Replace damaged parts.

24

Page 23 Page 25
Image 24
Page 23 Page 25
Contents Sears HP Electric Start 36 Mower Speed Lawn RiderSafety is Involved Safe Operation Practices for Ride-On MowersII. Slope Operation III. ChildrenProduct Specifications Full 90 DAY Warranty on BatteryMaintenance Agreement Customer ResponsibilitiesMaintenance EnginePerformance Sparkplug Muffler AIR Filter Stabilizer Blades BeltsTable of Contents Contents of Hardware Pack Tools Required for Assembly To Remove Unit from CartonBefore Rolling Unit OFF Skid Unpack CartonAssembly HOW to SET UP Your TractorChecklist All assembly instructions have been completedOperation Know Your Lawn RiderTo USE Throttle Control See Fig To Move Forward and BackwardSee Figs To SET Parking Brake See FigTo Adjust Mower Cutting Height Before Starting the EngineTo Operate Mower See Figs To TransportImportant When Operating in Temperatures Mowing TipsADD Gasoline Maintenance Lubrication ChartGeneral Recommendations Before Each USELawn Rider Blade CareBlade Removal See Fig Brake OperationTo Clean Battery and Terminals EngineAIR Filter See Fig Transaxle CoolingCleaning AIR Screen See FigMuffler Spark PlugsTo Install Mower See Fig Mower Upstop Adjustment See FigLawn Rider To Remove Mower See FigService and Adjustments To Level Mower Housing See FigViewed from Front of Tractor To Adjust Brake See Fig To Adjust Steering Wheel AlignmentKeeper To Replace Motion Drive Belt See FigTo Start Engine with a Weak Battery See Fig To Remove Hood See FIGTo Remove Wheel for Repairs See Fig To Replace FuseTo Adjust Carburetor See Fig To Adjust Throttle Control CablePreliminary Setting EngineBattery OtherTractor Fuel SystemTroubleshooting Points Problem Cause CorrectionProblem Cause CorrectionSchematic Wheels Tires DecalsKEY Part Description NO. no USAElectrical Electrical KEY Part DescriptionStandard Hardware - Purchase Locally Hood UNCStandard Hardware - Purchase Locally 129965 Case, Battery Fender / ChassisFrame 19132012 WasherSeat Locknut, Hex, Larg, Flange1011 DashStandard Hardware Purchase Locally Steering Wheel KEY Part NO. no DescriptionLower, Steering Sector Gear / Axle Support Link, DragBolt, Hex Front Axle Cap, Spindle25/32 x 1-5/8 x 16 Gauge Standard Hardware Purchase LocallyBrake / Rear Mower Lift Assembly KEY122504X Hardware Shown LargerEngine / Throttle Standard Hardware PurchaseGround Drive Keeper, Ground Drive Belt, IdlerArm, Ground Drive Clutch Idler, Flat2530 TransaxlePulley Mower Lift Lever Clip, Fuel Line106932X STD560907Mower Deck Mower Deck FOOTE/DANA Transaxle Model Number 2631 2732FOOTE/DANA TRANSAXLE- Model Number Briggs & Stratton Engine Model Number 283707, Type Number 2653O7 219 422224 138 445 66S42.1 310 801490450 399265 Bearing, Cylinder Requires Special 22406193805 391086635 66538 Mounting224546 Sighting Guide Only Ride UP and Down HILL, not Across Hill Sight and Hold this Level with SKY Line or TreeMAX HOW to Order Repair Parts Model Number 917,25746219.91

917.257462 specifications

The Sears 917.257462 is a well-known lawn tractor that has earned a reputation for its reliable performance and robust build. Designed for homeowners with medium to large yards, this model combines functionality and ease of use, making it an excellent choice for both novice and experienced gardeners.

One of the standout features of the Sears 917.257462 is its powerful engine. Equipped with a reliable, air-cooled, four-stroke engine, it offers ample horsepower to handle various mowing tasks. The engine's efficient design ensures that it provides consistent power while maintaining fuel economy, allowing owners to tackle extensive lawn areas without frequent refueling.

The cutting system of the Sears 917.257462 is designed for efficiency and versatility. It boasts a durable, reinforced mowing deck that allows for multiple cutting heights, accommodating different grass types and lawn conditions. This adaptability makes it easy to achieve a clean, even cut, regardless of the lawn's terrain. Additionally, the tractor features a bagging system that aids in collecting grass clippings for a tidy finish.

Ergonomics play a crucial role in the design of the Sears 917.257462. The operator's seat is adjustable, providing comfort and promoting good posture during extended use. The steering system is responsive, facilitating easy maneuverability around obstacles in the yard. The controls are intuitively placed, making it simple for users to operate the tractor while focusing on the task at hand.

Another key characteristic of this tractor is its durability. Constructed with high-quality materials, the Sears 917.257462 is built to withstand the rigors of regular use. Its robust frame and fortified components contribute to its longevity, minimizing the need for frequent repairs or replacements.

Furthermore, the tractor’s maintenance requirements are straightforward. Users will find that routine upkeep is manageable, thanks to accessible engine compartments and clear instructions for oil changes and blade sharpening. This ease of maintenance not only saves time but also contributes to the tractor's overall longevity.

In summary, the Sears 917.257462 is a formidable lawn tractor that combines a powerful engine, versatile cutting capabilities, ergonomic design, and durable construction. Its user-friendly features, coupled with low maintenance requirements, make it an ideal choice for those looking to maintain their lawns with efficiency and ease. Whether grooming a small yard or tackling larger landscapes, this model remains a reliable partner in lawn care.
Top Page Image Contents