Maintenance & Adjustments
Maintenance
Warning! Before performing any maintenance or repairs, disengage the PTO, move the drive control levers fully outward in the neutral position, engage the parking brake, stop the engine and remove the key to prevent unintended starting.
Engine
Refer to the Kohler Owner’s Manual for all engine maintenance intervals, procedures, specifications and instructions.
Changing the Engine Oil
Warning! If the engine has been recently run, the engine, muffler and surrounding metal
surfaces will be hot and can cause burns to the skin. Exercise caution to avoid burns.
To complete an oil change, proceed as follows:
1.Run the engine for a short time to warm the engine oil. The oil will flow more freely and carry away more impurities. Use care to avoid burns from hot oil.
2.Locate the oil drain port on the right side of the engine.
3.Pop open the protective cap on the end of the oil drain valve to expose the drain port. Refer to Figure
4.Push the oil drain hose (packed with this manual) onto the oil drain port. Route the opposite end of the hose into an appropriate oil collection container with at least a 2.0 quart capacity, to collect the used oil.
5.Pinch the tabs on the oil drain valve, then pull outward to begin draining oil. See Fig
Dipstick/
Oil Fill Cap
Oil Fill
Tube
Oil
Filter
6
6.After the oil has finished draining, push the end of the oil drain valve back in, until the tabs click into place.
7.Replace the oil filter, and refill the engine with new oil as instructed in the Kohler Owner’s Manual.
Air Cleaner
Service the
Spark Plug
The spark plugs should be cleaned and the gap reset once a season. Refer to the Kohler Owner’s Manual for correct plug type and gap specifications.
Hydrostatic Transmission
The zero turn tractor is equipped with dual integrated hydrostatic pumps/transaxles that are sealed and are
General Battery Information
warning!
•Should battery acid accidentally splatter into the eyes or onto the skin, rinse the affected area immediately with clean cold water. If there is any further discomfort, seek prompt medical attention.
•If acid spills on clothing, first dilute it with clean water, then neutralize with a solution of ammonia/water or baking soda/water.
•NEVER connect (or disconnect) battery charger clips to the battery while the charger is turned on, as it can cause sparks.
•Keep all sources of ignition (cigarettes, matches, lighters) away from the battery. The gas generated during charging can be combustible.
•As a further precaution, only charge the battery in a well ventilated area.
•Always shield eyes and protect skin and clothing when working near batteries.
•Batteries contain sulfuric acid and may emit explosive gases. Use extreme caution when handling batteries. Keep batteries out of the reach of children.
Figure
19