Yazoo/Kees ZEKW42170, ZEKW52210 manual Replacing the Air Filter Kawasaki Engine, Maintenance

Page 43
Replacing the Air Filter Kawasaki Engine

MAINTENANCE

Replacing the Air Filter Kawasaki Engine

Standard air filter

WARNING!

The engine and the exhaust system, become very hot during operation.

Risk for burns if touched.

Allow engine and exhaust system to cool at least two (2) minutes.

1.Remove the plastic fastener on the top of the air filter cowling and remove the air filter cowling.

2.Remove the foam rubber pre-filter and clean using a mild detergent.

Squeeze it dry with a clean cloth.

3.Remove the wing nuts for the air filter and remove the paper filter. Tap the paper filter against a fixed surface to remove dust. If the paper filter is still dirty, it must be replaced.

IMPORTANT INFORMATION

Do not used compressed air to clean the air filter.

Do not wash the paper filter. Do not oil the paper filter.

4.Refit the air filter as follows:

Check that the seal on the bottom of the paper filter is whole.

Mount the paper filter in the air filter housing and tighten the wing nuts.

5.Refit the pre-filter on the paper filter.

6.Replace the cowling over the air filter housing. Do not over tighten the plastic fastener.

8011-768-2

Remove the air filter cowling

8011-557

Remove the pre-filter

Remove the paper filter

8011-558

 

 

 

 

8009-181

Remove dust

English-41

Image 43
Contents 968999296/ZEKW52210 Operator’s manualModels 968999295/ZEKW42170Page OPERATOR’S MANUAL ContentsZE RIDER English-2 General INTRODUCTIONIntroduction CongratulationsManufacturing Number Good ServiceSymbols and Decals SYMBOLS AND DECALSRead Safety Instructions SAFETY INSTRUCTIONSGeneral Operation English-8 Slope Operation Personal Safety EquipmentChildren Maintenance General Maintenance Use protective goggles IMPORTANT INFORMATION TransportCustomer responsibilities Controls CONTROLSControl Locations 2. Motion Control Levers 1. Parking Brake1. Forward 4. Seat adjustment boltsTracking 3. Fuel Shut Off Valve5. Refueling 7. Fuses 6. By pass linkage8. Hour Meter 10. Ignition Switch9. Choke Control 11. Throttle Control 12. Blade switch13. Cutting height pedal AccessoriesOperation OPERATIONTraining Starting the Engine Before Starting6.Move the throttle to the middle position 8.Open the fuel shut off valve IMPORTANT INFORMATION To start an engine with a weak battery Running Operating on hills Mowing patterns Mowing TipsStopping the Engine the parking brake is on Moving by Handthe engine stopped the ignition key has been removedMaintenance MAINTENANCEMaintenance Schedule The ignition key has been removed The engine is stoppedThe parking brake is on Battery Ignition System Checking the Safety System 2. Throttle cable Checking and Adjusting the Throttle CableChecking and Adjusting the Choke Cable Checking the Engines Cooling Air IntakeStandard air filter Replacing the Air Filter Kawasaki EngineChecking the Fuel Pump’s Air Filter Replacing the Fuel FilterChecking Tire Pressures Faulty adjustment can cause an accident Checking the Parking BrakeChecking the V-belts Deck beltDeck belt installation IZT belt Checking the Blades Blade replacement Adjusting the Mower Deck To adjust anti-scalprollers Use protective glasses when cleaning and washing Cleaning and WashingCaster Wheels HardwareMower is tracking to the right Tracking adjustmentParking brake To adjust parking brakeZE LUBRICATIONLubrication Lubrication Schedule3. Deck spindle Lubricating the Cables1. Front Wheel Mount 2. Front Wheel Bearings4. Deck outer spindle Checking the Oil Level Transaxle Transmission Fluid Change 6. Changing the Engine Oil Filter14.Proceed to the purge procedure Purging Procedures Trouble Shooting Guide TROUBLE SHOOTING GUIDEWater in the fuel Uneven mowing results Winter Storage ServiceSTORAGE StorageWiring diagram WIRING DIAGRAMS1 13 11 5 12 Technical Data TECHNICAL DATAEquipment Overall dimensionsProductivity Torque Specifications Conformity Certificates CONFORMITY CERTIFICATESUSA requirements Service Journal SERVICE JOURNALDelivery Service 1. Change engine oil After the First 5-8HoursEnglish-69 6.Check/clean the engine’s cooling air intake 25-HourService4.Check battery with cables 5.Lubricate according to lubrication chart5.Check/adjust the parking brake 50-HourService1.Perform the 25-hourservice 4.Lubricate according to lubrication chart3.Change the engine oil filter 100-HourService2.Perform the 50-hourservice 4.Clean/replace the spark plugs300-HourService At Least Once Each Year English-75 English-76 English-77