Scotts S1642, S1742, S2046 manual Adjusting Mower Gage Wheels, Adjusting Mower Level Side-to-Side

Page 21

Adjusting Mower Gage Wheels

OPERATING MOWER

4.Adjust gage wheels to match cut height desired. (See Adjusting Mower Gage Wheels below.)

Adjusting Mower Gage Wheels

CAUTION: Avoid injury! Before you adjust gage

wheels: STOP engine, remove key, and wait for blades to STOP.

IMPORTANT: Avoid damage! Mower gage wheels must not ride on ground to support mower weight. Adjust gage wheels each time you change cutting height.

1.Check tractor tire pressure. Inflate tires to the correct pressure. (See Checking Tire Pressure in Service - Miscellaneous section.)

2.Raise mower lift lever to TRANSPORT (upper) position and adjust cutting height. (See Adjusting Cutting Height in this section.)

D
C	A
	A
	B
	M88571

3.Remove bolt (A), bushing (B), washer (C), and nut (D).

4.Move lift lever down to desired MOWING position.

5.Move mower gage wheels, one on each side, to one of four holes for desired position. On 46-Inch Mower Deck, move front and rear gage wheels.

6.Bottom of gage wheels should be approximately 6-13 mm (1/4-1/2 in) from the ground when properly adjusted.

7.Install bolt and tighten with nut.

Adjusting Mower Level (Side-to-Side)

CAUTION: Avoid injury! Before you adjust

mower: STOP engine, remove key, and wait for blades to STOP.

Be careful, sharp edges on mower blades. Always wear gloves when handling mower blades.

NOTE: A deck leveling gauge (Part Number TY15272) to aid in deck leveling may be obtained through your local Authorized Service Center at a nominal cost.

1.Park tractor on a hard, level surface.

2.Stop engine and remove key.

3.CHECK: Tire pressures must be correct. (See Checking Tire Pressure in Service – Miscellaneous section.)

4.Adjust cutting height to middle position.

AA

5.Turn left blade parallel to tractor axle. Hold drive belt and turn right blade parallel to axle.

A

M40161

6.Measure from each outside blade tip (A) to the level surface. The difference between measurements must not be more than 3 mm (1/8 in).

Operating Mower - 17

Image 21

Contents Scotts Lawn Tractors OPERATOR’S MANUALS1642, S1742, and S2046 OMGX10784 C0INTRODUCTION THANK YOU for purchasing a Scotts productCALIFORNIA Proposition 65 Warning Record Identification Numbers PRODUCT IDENTIFICATIONConnect and Check Battery ASSEMBLYIdentify Parts 42-Inch Mowers OnlyChecking Tire Pressure SAFETY SIGNS Safety-Alert SymbolMachine Safety Labels Emission Compliance Period Emission Control System Certification LabelCertification THROWN OBJECTSCONTROLS Tractor Controls - GearTractor Controls - Automatic OPERATING MACHINE Operate SafelyPark Safely Avoid Tipping Adjusting SeatWear Appropriate Clothing Transport SafelyStarting Engine Using the Park BrakeCold Weather Starting Tips Using Throttle ControlWarming and Idling Engine On Automatic TransmissionUsing Travel Controls - Automatic Using Travel Controls - GearStopping Engine CAUTION Avoid injuryUsing Cruise Control Using Reverse Implement Option ENGAGE CRUISE CONTROLDISENGAGE CRUISE CONTROL Testing Safety Systems Daily Operating ChecklistPushing Machine TestTest IMPORTANT Avoid damage! On Automatic Using Rear Wheel Weights Using Front WeightsAvoid Using Ground Engaging Equipment Using Tire ChainsAdjusting Cutting Height Using Lift Lever to Raise and Lower MowerOPERATING MOWER Operate Mower SafelyAdjusting Mower Level Side-to-Side Adjusting Mower Gage WheelsCAUTION Avoid injury! Before you adjust gage CAUTION Avoid injury! Before you adjustEngaging and Disengaging Mower Adjusting Mower Level Front-to-RearDismounting to Inspect or Unplug Mower or Optional Bagger Using Mower Deck Side Discharge - 42-Inch Mower DecksUsing Mower Deck with Optional Equipment - 42-Inch Mower Decks Using Mower Deck Mulch Ready - 42-Inch Mower DecksA must be removed 1. Remove mulch cover Lift plastic discharge chute REPLACEMENT PARTS Service LiteratureJohn Deere Quality Parts for 46-Inch Mower Deck Parts for 42-Inch Mower DeckSERVICE MACHINE SAFELY Practice Safe MaintenanceHandling Waste Product and Chemicals Service Intervals SERVICE INTERVAL CHARTService Record SERVICE PERFORMEDDATE Engine Warranty Maintenance Statement SERVICE ENGINEAdjusting Carburetor Make sure engine is COLD when checking engine oil levelCAUTION Avoid injury! Engine may be hot, be careful not to burn hands Changing Engine Oil and FilterChecking and Cleaning Air Cleaner Elements - S1642 and S1742 S1742S1642NOTE DO NOT wash paper element Checking and Cleaning Air Cleaner Elements - S2046 Replacing Fuel Filter Checking Spark PlugsClean Air Intake Screen and Engine NOTE Change filter when fuel is low in fuel tankIMPORTANT Avoid damage! To avoid overheating Adjusting Brakes - Gear SERVICE STEERING AND BRAKESGrease Lubricating Front Wheel Spindles, Wheel Bearings and Axle PivotAdjusting Brakes - Automatic Hand Control G D F Adjusting Brakes - Automatic Foot ControlAdjusting Mower Belt Tension SERVICE MOWERMower Spindles Replacing Mower Drive BeltAdjusting Spindle Brake Servicing Mower Blades Checking Mower BladesM88119b CD B A E D C B AE C D B A Balancing Blades Sharpening BladesChecking the Battery SERVICE ELECTRICALClean Battery and Terminals Removing and Installing the BatteryCharging the Battery Replacing Headlight Bulb Using Booster BatteryReplacing Fuse M88559MX1535 Fuel SERVICE MISCELLANEOUSUsing Fresh Fuel and Stabilizers Using Clean FuelsOctane Rating Fuel BlendsCare for Plastic and Painted Surfaces PAINTED METAL SURFACESM96452 SERVICE MISCELLANEOUS Removing Mower REMOVING MOWERREMOVING MOWER Installing Mower INSTALLING MOWERQ P O N TROUBLESHOOTING Using Troubleshooting ChartEngine CHECK Mower Electrical Storing Safely STORING MACHINEPreparing Machine for Storage Preparing Engine For StorageRemoving Machine From Storage NOTE The stored battery should be recharged every 90 daysModel S1642 SPECIFICATIONSModel S1742 Model S2046Electrical System All Models Dimensions All ModelsFuel All Models Tires All ModelsMower Deck 42-Inch Mower Deck 46-InchRecommended Lubricants WARRANTY WARRANTYEQUIPMENT USE TERMJohn Deere Emission Control System Warranty Coverage Your Warranty Rights and ObligationsOwner’s Warranty Responsibilities Length Of Warranty CoverageWarranty Service And Charges NOTE Applicable in North America onlyMaintenance Warranty Coverage Consequential Warranty CoverageWarranty Period Warranty CodeINDEX INDEX Please do not return this tractor to the store where you purchased it QUALITY STATEMENTStep