Scotts S1642, S1742, S2046 manual Removing Machine From Storage, Storing Machine

Page 62

NOTE: The stored battery should be recharged every 90 days.

STORING MACHINE

7.Clean the engine and engine compartment.

8.Remove battery.

9.Clean the battery and battery posts.

NOTE: The stored battery should be recharged every 90 days.

10.Charge the battery. (See Charging Battery in the SERVICE - ELECTRICAL section.)

11.Store the battery in a cool, dry place where it will not freeze.

12.Store the vehicle in a dry, protected place. If vehicle is stored outside, put a waterproof cover over it.

Removing Machine From Storage

1.Check tire pressure. (See Checking Tire Pressure in Service - Miscellaneous section.)

2.Fill fuel tank. Check engine oil level.

3.Take machine off of blocks or support stands.

4.Charge battery if necessary. Install battery. (See Removing and Installing the Battery in the SERVICE- ELECTRICAL section.)

5.Check spark plug gap. Install and tighten spark plug(S) to 20 N•m (15 lb-ft.).

6.Lubricate all grease points.

7.Check automatic transmission oil level.

8.Run the engine 5 minutes without the mower or any attachments running to allow oil to be distributed throughout engine.

9.Be sure all shields and guards are in place.

Storing Machine - 58

Image 62

Contents S1642, S1742, and S2046 OPERATOR’S MANUALScotts Lawn Tractors OMGX10784 C0CALIFORNIA Proposition 65 Warning INTRODUCTIONTHANK YOU for purchasing a Scotts product PRODUCT IDENTIFICATION Record Identification NumbersIdentify Parts ASSEMBLYConnect and Check Battery 42-Inch Mowers OnlyChecking Tire Pressure Machine Safety Labels SAFETY SIGNSSafety-Alert Symbol Certification Emission Control System Certification LabelEmission Compliance Period THROWN OBJECTSTractor Controls - Automatic CONTROLSTractor Controls - Gear Park Safely OPERATING MACHINEOperate Safely Wear Appropriate Clothing Adjusting SeatAvoid Tipping Transport SafelyUsing the Park Brake Starting EngineWarming and Idling Engine Using Throttle ControlCold Weather Starting Tips On Automatic TransmissionStopping Engine Using Travel Controls - GearUsing Travel Controls - Automatic CAUTION Avoid injuryUsing Cruise Control DISENGAGE CRUISE CONTROL Using Reverse Implement OptionENGAGE CRUISE CONTROL Pushing Machine Daily Operating ChecklistTesting Safety Systems TestTest IMPORTANT Avoid damage! On Automatic Avoid Using Ground Engaging Equipment Using Front WeightsUsing Rear Wheel Weights Using Tire ChainsOPERATING MOWER Using Lift Lever to Raise and Lower MowerAdjusting Cutting Height Operate Mower SafelyCAUTION Avoid injury! Before you adjust gage Adjusting Mower Gage WheelsAdjusting Mower Level Side-to-Side CAUTION Avoid injury! Before you adjustAdjusting Mower Level Front-to-Rear Engaging and Disengaging MowerUsing Mower Deck Side Discharge - 42-Inch Mower Decks Dismounting to Inspect or Unplug Mower or Optional BaggerUsing Mower Deck Mulch Ready - 42-Inch Mower Decks Using Mower Deck with Optional Equipment - 42-Inch Mower DecksA must be removed 1. Remove mulch cover Lift plastic discharge chute John Deere Quality REPLACEMENT PARTSService Literature Parts for 42-Inch Mower Deck Parts for 46-Inch Mower DeckHandling Waste Product and Chemicals SERVICE MACHINE SAFELYPractice Safe Maintenance SERVICE INTERVAL CHART Service IntervalsDATE Service RecordSERVICE PERFORMED Adjusting Carburetor SERVICE ENGINEEngine Warranty Maintenance Statement Make sure engine is COLD when checking engine oil levelChanging Engine Oil and Filter CAUTION Avoid injury! Engine may be hot, be careful not to burn handsNOTE DO NOT wash paper element Checking and Cleaning Air Cleaner Elements - S1642 and S1742S1742S1642 Checking and Cleaning Air Cleaner Elements - S2046 Checking Spark Plugs Replacing Fuel FilterIMPORTANT Avoid damage! To avoid overheating Clean Air Intake Screen and EngineNOTE Change filter when fuel is low in fuel tank Grease SERVICE STEERING AND BRAKESAdjusting Brakes - Gear Lubricating Front Wheel Spindles, Wheel Bearings and Axle PivotAdjusting Brakes - Automatic Hand Control Adjusting Brakes - Automatic Foot Control G D FMower Spindles SERVICE MOWERAdjusting Mower Belt Tension Replacing Mower Drive BeltAdjusting Spindle Brake M88119b Servicing Mower BladesChecking Mower Blades E C D B A CD B AE D C B A Sharpening Blades Balancing BladesClean Battery and Terminals SERVICE ELECTRICALChecking the Battery Removing and Installing the BatteryCharging the Battery Using Booster Battery Replacing Headlight BulbMX1535 Replacing FuseM88559 SERVICE MISCELLANEOUS FuelOctane Rating Using Clean FuelsUsing Fresh Fuel and Stabilizers Fuel BlendsM96452 Care for Plastic and Painted SurfacesPAINTED METAL SURFACES SERVICE MISCELLANEOUS REMOVING MOWER Removing MowerREMOVING MOWER INSTALLING MOWER Installing MowerQ P O N Engine TROUBLESHOOTINGUsing Troubleshooting Chart TROUBLESHOOTING Mower Electrical Preparing Machine for Storage STORING MACHINEStoring Safely Preparing Engine For StorageNOTE The stored battery should be recharged every 90 days Removing Machine From StorageModel S1742 SPECIFICATIONSModel S1642 Model S2046Fuel All Models Dimensions All ModelsElectrical System All Models Tires All ModelsRecommended Lubricants Mower Deck 42-InchMower Deck 46-Inch EQUIPMENT USE WARRANTYWARRANTY TERMOwner’s Warranty Responsibilities Your Warranty Rights and ObligationsJohn Deere Emission Control System Warranty Coverage Length Of Warranty CoverageMaintenance Warranty Coverage NOTE Applicable in North America onlyWarranty Service And Charges Consequential Warranty CoverageWarranty Code Warranty PeriodINDEX INDEX Step Please do not return this tractor to the store where you purchased itQUALITY STATEMENT