Guardian Technologies 004721-0, 004725-3 Weld Stud Under Roof Panel for Access Cover Cable

Page 34

Section 9 - Exploded Views and Parts

Guardian Liquid-cooled 15 kW and 20 kW Generators Standard Compartment — Drawing No. 0E0771-F

		21	31
			30
		11	1
		11
	13
4	14	15
4

WELD STUD UNDER ROOF PANEL FOR ACCESS COVER CABLE

	16	"Y"
	11	26
		10 26
		17	11
			11
		18 19
9	5	4	15
			15
	8		17
	26	10	17
		10
24	6	18
25	6	18
25	2

22 23 20

NOTE:

USE DOOR LATCH FASTENER TO SECURE GROUND WIRE.

NOTE:

USE LOCTITE ON NUTS ITEM #26.

32 Generac® Power Systems, Inc.

Image 34

Contents Liquid-cooled, Prepackaged Standby Generators ‹ HOW to Obtain Service Authorized Service Dealer Location‹ Operation and Maintenance IntroductionIntroduction IFC Safety Rules General Hazards Electrical Hazards Automatic System Operation Transfer SwitchGenerator Generator AC Connection Systems‹ 1.7.3 LOW Coolant Level Switch ‹ 1.7.1 LOW OIL Pressure Switch‹ 1.7.2 High Coolant Temperature Switch Engine Protective DevicesUnpacking Lifting the Generator‹ 1.10.1 Generator Specifications SpecificationsReconfiguring the Fuel System ‹ 1.10.2 Engine SpecificationsEngine OIL Recommendations Torque SpecificationsCoolant Recommendations Basic Standby Electric System Generator LocationGenerator Mounting Support ‹ 2.1.1 Nfpa StandardsTotal Circuit Isolation Method Transfer Switch Start Signal ConnectionsEmergency Circuit Isolation Method Grounding the Generator‹ 2.10.1 Vented Batteries Battery InstallationPreparation Before START-UP ‹ 2.11.1 Prior to Initial START-UPUsing a Standard GTS Transfer Switch Manual Transfer START-UP Automatic Operation Control Console ComponentsWeekly Exercise Cycle Once Every SIX Months Engine HeaterEvery Three Months Once AnnuallyChecking Fluid Levels Cooling SystemOverload Protection for Engine DC Electrical System ‹ 4.5.3 Exercise System ‹ 4.5.2 Check Battery‹ 4.5.1 Check Engine OIL Level ‹ 4.5.4 Inspect Cooling System‹ 4.6.1 Cleaning the Generator Miscellaneous Maintenance‹ 4.5.11 Changing the Engine AIR Cleaner ‹ 4.5.13 Coolant Change‹ 4.6.3 Battery Maintenance ‹ 4.6.4 Battery ReplacementScheduled Maintenance Service Maintenance Interval InformationLevel Maintenance Level Troubleshooting Points Problem Cause CorrectionGuardian Liquid-cooled 15 kW, 20 kW and 25 kW Generators Guardian Liquid-cooled 15 kW, 20 kW and 25 kW Generators Installation Diagram Section Electrical Data Customer Connection 120/240V 1-PHASE Electrical Data Cover Connector Housing Housing Governor ConnectorConnector Interface Assembly ASM Motor StepperDampener Vibration Base Mounting 1.5L Stnrd & AcstcWasher Shakeproof EXT 5/16 STL Washer Flat 5/16 ZincWeld Stud Under Roof Panel for Access Cover Cable Assembly Cover Access Assembly BASE-DOOR Ground WireGRD Wire Assy 99HSB Cover Access GENWeld Stud Under Roof For Access Cover Cable Washer Self Locking Dome Roof Acstc & Stnd Cmprtmnt 1.5LDoor Weldment 1.5 EPS Baffle Cntrl PNL 1.5L AcousticTo a Hourmeter Wire AssemblySilksc Holder FuseWaterpump Hardware Ground Wire Starter Switch OIL PressureARM Adjust Alternator Clamp for Wiring Harness not Shown16 7 Venturi 1.5L Modine Tank Coolant RecoveryRadiator 1.5L Guard FAN 1.5L ModineVapor Weldment Mounting Base Cover AIR CleanerGasket AIR Cleaner Adapter Flange Fuel Inlet16 30 21 Assy Rotor 15KW Housing BlowerAssy Rotor 10KW Assy Rotor 20KWBRACKET, Battery Hold Down ASSY,WIRE#16 REDBOOT, Battery Cable Battery Post Cover RED+Saddle 2 Inch Manifold Exhaust 1.5LNipple TOE 1.5NPTX5.5 BLK Iron PIPE,EXHAUST 1.5L STNDRD&ACSTCMANUFACTURER’S Emission Control System Warranty Coverage Your Warranty Rights and ObligationsPURCHASER’S/OWNER’S Warranty Responsibilities Emission Control System Warranty Emission Related Parts Include the FollowingWarranty Schedule