Dixon ZTR 5005, ZTR 5004 manual Neutral Adjustment

Page 50

CARE AND MAINTENANCE

NEUTRAL ADJUSTMENT:

1.Engage parking brake and raise rear of frame with jack or blocks so that rear tires do not contact the ground.

2.Swing out the control levers, start the engine, and release the paking brake.

3.Raise the upper body to access hydro control linkage. If right wheel creeps, adjust right side linkage and vice-versa. Use procedure below.

a.loosen, but do not remove, the bolt in the control tube (5540)

b.loosen jam nuts on ends of the control rod (9067)

c.turn control rod in or out until neutral

is achieved

d.tighten jam nuts on control rod

e.tighten bolt in control tube

50

Image 50

Contents Series Important Read Carefully Safety Warranty Policy IndexSafety Blade Contact TIP Over RUN Over Back OverSafety Alert Symbol General Operation General Operation Slope Operation Do notChildren Never allow children to operate the mowerService Service Dixon Limited Warranty Policy Hydro Gear Models 5000 6000 7000 Series MowersSpecifications Specifications Model ZTRSeat Adjustment Instructions Controls Control LeversChoke Control Lever Throttle Control LeverTo SET Parking Brake Parking BrakeHydro Gear System Mower Deck CUT Height Lift Lever Blade DriveCircuit Breaker To Free Wheel Machine Unlock Transmission Operation Instructions TowingBefore Operating Mower Parking Brake Switch Test Engine should StopSide Discharge of the Clippings Grass Height and Cutting Suggestions Starting Instructions engine has been operated Starting Instructions cold engine Mowing with a Mulching Attachment Mowing with a Mulching Attachment CUT High MOW OftenMowing with a Grass Catcher Attachment Mowing with a Grass Catcher Attachment Deck Rollers 60 deck Care and Maintenance Maintenance ScheduleEngine BatteryOFF Season Battery Storage TiresCutter Blade Maintenance Belts Belt TensionChassis Fuel Shut OFF ValveLubrication LocationsChanging the Engine OIL OIL Fill OIL FiltersHydrostatic Transmission OIL & Filter Service Care and Maintenance OIL Requirements Service IntervalsRecommended OIL Weight PARTS/SERVICE Cleaning the MowerWarranty Electrical SystemsMower Deck Leveling Procedure Mower Deck Leveling Procedure Mower Deck Removal BOX to Hydrostat Belt Adjustment Parking Brake Cable Adjustment Rear Wheels Wheel ReversalNeutral Adjustment Neutral Adjustment Procedure for Electric Clutch Adjustment AIR GAP AdjustmentOhms Test Forward Travel Speed Adjustment Troubleshooting Drive System Engine Stalls When Blades are EngagedEngine Runs but Mower WON’T Move Forward CUT QualityStandard Service Parts List DeckKawasaki and Kohler AIR & OIL Filter Part Numbers Owner Information Name AddressZTRMowers