Dixon 502 manual Index Safety

Page 2

		INDEX
1.	SAFETY	Pages	1	- 3
2.	WARRANTY POLICY	Page	4
3.	SPECIFICATIONS	Page	5
4.	SET UP AND SERVICE	Pages	6 - 1 1
5.	OPERATION INSTRUCTIONS	Pages	12 - 13
6.	CARE AND MAINTENANCE	Pages	14	- 21
7.	TROUBLE SHOOTING	Pages	22	- 24
8.	PARTS ILLUSTRATIONS	Page	29
9.	ELECTRICAL SCHEMATIC	Page	30
10.	PARTS LIST	Pages	31	- 33

Image 2

Contents Page Index Safety See your dealer for warranty service, parts and repairs Important Read CarefullyAlways look behind you before backing up Satisfactory use of this productSafety Safety Reminders Read Carefully Before Operation Safety Reminders Alcohol or drugsPage Chassis 11 GA rectangular tube Specifications Subject to Change Without NoticeBlade Drive Warner electric clutch Seat assembly instructions SET UP and ServiceSeat Assembly Instructions Flat washer and jam nut. See Illustration Repeat above procedure on left sideRaise rear body cover to fully open position Mower Deck Installation Position mower deck under chassisLeveling the Deck Adjustment PointsLeveling Principals Remove battery from chassis Final PreparationSound judgment by the owner will prevent accidents No shifting or clutching requiredThrottle Control Lever Light SwitchOperation Instructions Mower Deck CUT Height Lift LeverCare and Maintenance Model Maintenance ScheduleBelt Tension Reverse procedure to re-install deck assemblyCutter Blade Removal Repeat above procedures on opposite hydrostat Page Adjustment Points for T-BOX Belt Tension Forward lever stop adjustment Each front wheel caster Primary and final driveZerks used OperationCare and Maintenance Model Cleaning the Mower Improper blades Uneven tire pressures Trouble Shooting Mower CUT QualityPoor cut quality Reduce mowing speedRepair Drive adjustmentSide or the other Manual Box belts slippingLow battery condition Battery Required Battery water lowMower Battery discharge Clutch switchDeck Assembly Model 5O2 Body Assembly Model BOX and Hydrostats Assembly Model Chassis Assembly Model Fuel & Hydraulics Tanks & Fittings Assembly Model Wiring Assembly Model Fuel Cap/Gauge LH Slide Angle1471 Seat Slide 4199 Light Switch 5577 Drive Chain-Secondary 4569 Lower Wiring Loom4013 Wire Tie 4216 Battery Ground Cable 5581Rear Tire Headlight BulbRear Rim Seat Frame