Exmark 4500-497 manual California

Page 2

WARNING

CALIFORNIA

Proposition 65 Warning

The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm.

Important: When the mower is used or operated on any California forest, brush or grass covered land, a working spark arrester must be attached to the muffler. If not, the operator is violating state law, Section 4442 Public Resource Code. To acquire a spark arrester for your unit, see your Engine Service Dealer.

This spark ignition system complies with Canadian ICES-002 Ce système d’allumage par ètincelle de vèhicule est conforme à la norme NMB-002 du Canada

The enclosed Engine Owner’s Manual is supplied for information regarding The U.S. Environmental Protection Agency (EPA) and the California Emission Control Regulation of emission systems, maintenance and warranty.

Keep this engine Owner’s Manual with your unit. Should this engine Owner’s Manual become damaged or illegible, replace immediately. Replacements may be ordered through the engine manufacturer.

Exmark reserves the right to make changes or add improvements to its products at any time without incurring any obligation to make such changes to products manufactured previously. Exmark, or its distributors and dealers, accept no responsibility for variations which may be evident in the actual specifications of its products and the statements and descriptions contained in this publication.

© 2008—Exmark Mfg. Co., Inc.

 

Contact us at www.Exmark.com.

Industrial Park Box 808

 

Printed in the USA

2

Beatrice, NE 68310

All Rights Reserved

Image 2
Contents Frontrunnertm California Introduction Contents Safe Operating Practices SafetySafety Alert Symbol TrainingSafety Operation Using the Rollover Protection System Rops Slope OperationMaintenance and Storage Safety Safety and Instructional Decals 109-2355 109-2356 109-2358 109-2377 109-2396 109-7413 116-1003 109-2360 Systems SpecificationsModel Numbers Cutting Deck Hydrostatic Ground Drive SystemTires & Wheels Dimensions Torque RequirementsControls Product OverviewOperation Pre-Start Open the Fuel Shut-Off Valve Operating InstructionsRaise the Rollover Protection System Rops Starting the EngineStopping the Engine Driving the MachineDisengaging the PTO Transporting Transporting a UnitLoading a Unit Maintenance Recommended Maintenance SchedulesCheck Battery Charge Check Engine Oil LevelCheck Safety Interlock System Engine must initiate shutdownCheck Seat Belt Check Rollover Protections Systems Roll Bar PinsService Air Cleaner Check for Loose HardwareCheck Condition Of Belts Check Auxiliary Hydraulic Oil LevelCheck Tire Pressures Lubricate Grease FittingsLubricate Rear Caster Wheel Hubs Pumps PlacesLubricate Brake Rod Bushings Lubricate Motion Control ShaftLubricate Brake Handle Pivot Lubricate Motion Control Bronze BushingsCheck Wheel Hub Locknuts Fuel Tank Mounting Hardware SpecificationsChange Hydraulic System Filter Thread Locking AdhesivesDielectric Grease Pump Drive Belt ReplacementPark Brake Adjustment Pump Drive Belt TensionMotion Control Linkage Adjustment Weight Transfer Spring Adjustment Caster Pivot Bearings Pre-Load Adjustment Clutch ShimFeeler gauge Brake mounting bolt Cleaning Clean Engine Cooling SystemWaste Disposal Remove Engine Shrouds and Clean Cooling FinsBattery Disposal Motor Oil DisposalTroubleshooting Problem Possible Cause Corrective ActionTroubleshooting Schematics Ignition SwitchIgnition Switch 31HPElectrical Logic Schematic 27HP Kohler Black / Grey Rown BElectrical Logic Schematic 31HP Briggs & Stratton VioletHydraulic Diagram Exmark Commercial Turf Equipment Page Page Service Record Page Page See EXMARK’S Complete Line of Accessories and Options