Allstar Products Group HDSWG 1000 Technical Specifications, Physical Drive, Electrical

TECHNICAL SPECIFICATIONS

PHYSICAL

DRIVE

PAD:

OVERHEAD CLEARANCE: UNIT SIZE:

FRAME:

COVER: SHIPPING WEIGHT:

24W x 30D x 3H

21 Inch Minimum

16-1/8 x 24-7/8 x 17-1/4

Welded steel, Coated to UL Standards Molded Polyethylene

150 lbs.

DRIVE SYSTEM: TORQUE LIMITER:

OUTPUT SHAFT: LIMITS:

60:1 Gearbox

Mounted on Output Shaft, Adjustable

1-1/4 Diameter Ball-Bearing Mounted

Independent Open & Close; Displaced Cam with Micro Switch

PRIMARY VOLTAGE: ELECTRICAL SOURCE:

CONTROL VOLTAGE:

RADIO RECEIVER POWER:

MOTOR:

ELECTRICAL

115 VAC, 60 Hz

One 3-Wire 15 AMP Service per Operator

12/24 VDC 24 VAC

1/2 HP, 4.4 AMP PSC, Instant Reversing

CAPACITIES

MAX. GATE WEIGHT: 1000 lbs.

MAX. GATE WIDTH: 18 Feet

MAX. CYCLES PER HOUR: 60 Open/Close per Hour 1200 Open/Close per Day

GATE SPEED: 13-15 Seconds for 90º Opening

Specifications subject to change without notice. Consult the factory.

Manufacturer’s Limited Warranty

Allstar warrants its gate operators to be free from defect in material and workmanship for a period of five (5) years from the date of purchase for single family home use and three (3) years from the date of purchase for multi-family and commercial use. This warranty covers all components except the electronic circuit boards which are warranted for three (3) years from the date of purchase for single family home use and two (2) years from the date of purchase for multi-family and commercial use. To obtain service contact your dealer.

To obtain service under this warranty the buyer must obtain authorization instructions for the return of any goods from Allstar before returning the goods. The goods must be returned with complete identification, with copy of proof-of-purchase, freight prepaid and in accordance with Allstar’s instructions or they will not be accepted. In no event will Allstar be responsible for goods returned without proper authorization or identification.

Goods returned to Allstar for warranty repair within the warranty period, which upon receipt by Allstar are confirmed to be defective and covered by this limited warranty, will be repaired or replaced at Allstar’s sole option, at no cost and returned pre-paid. Defective parts will be repaired or replaced with new or factory rebuilt parts at Allstar’s sole option.

This limited warranty does not cover non-defect damage, damage caused by unreasonable use, damage caused by improper installation or

care, vandalism or lightning, fire or excessive heat, flood or other acts of God (including, but not limited to misuse, abuse or alterations, failure to provide reasonable and necessary maintenance), labor charges for dismantling or reinstalling a repaired or replaced unit, or replacement batteries.

These warranties are in lieu of all other warranties, either expressed or implied. All implied warranties of merchantability and/or fitness for a particular purpose are hereby disclaimed and excluded. Under no circumstances shall Allstar be liable for consequential, incidental or special damages arising in connection with the use or inability to use this product. In no event shall Allstar’s liability for breach of warranty, breach of contract, negligence or strict liability exceed the cost of the product covered hereby. No person is authorized to assume for Allstar any other liability in connection with the sale of this product.

This warranty gives you specific legal rights. You may also have other rights which vary from state to state. Warranty effective after May 15th, 1997.

For Information:

Phone 610-436-6190 FAX 610-344-0210

c.p. Allstar Corporation Downingtown, PA 19335

This Gate Operator is built in the USA and complies with all requirements of Underwriters' Laboratories Standard UL-325. P/N 107765 Rev. A, 5/97

28