Manuals / Alto-Shaam / Kitchen Appliance / Oven

Alto-Shaam service, ASC-4G Gas Convection Oven - Electronic Control, Description, BK-34648

Models: ASC-4G

1 30

Page 25

service

	1	3
	1	2
		2

		17
15	16	14
		14
		13

9 10

ITEM	DESCRIPTION		PART No.	QTY	ITEM	DESCRIPTION		PART No.	QTY

1	Latch		LT-26976	2	12	cord		CD-34094	1

2	Door assembly, LH		DR-27850	1	13	Modular block		BK-34648	1

3	Side rack		Sr-26396	2	14	high limit		sw-34150	1

4	oven rack		sh-26795	6	15	power board supply		BS-33554	1

5	gasket	top/bottom	10006606	2	16	light relay, ignition relay		rl-33930	1
		side	1000605	2	17	motor relays		rl-33558	2

6	Feet			4	18	panel outer, RH		1006671	1

7	door assembly, RH		DR-27849	1	19	panel outer, top and LH		1006623	1

8	switch, fan, hi/lo		sw-34101	1	20*	Panel, louvered access		1006672	1

9	Panel overlay		PE-26729	1	21*	cover, bottom		1006678	1

10	ignition control w/ sensor		5010046	1	22*	fan, box	34CFM, 125V, 50-60Hz	fa-3973	1

11	solenoids valves		va-28189	2			70CFM, 125V, 50-60Hz	fa-3599	1

*Not Shown

Part numbers and drawings are subject to change without notice..

ASC-4G Gas Convection Oven - Electronic Control • 23

Page 25

Image 25

Alto-Shaam manual service, ASC-4G Gas Convection Oven - Electronic Control, Description, BK-34648, BS-33554

Contents

Maintenance InstallationModel OperationInstallation Care and CleaningService Wire Diagramsu n p A C k I n G D E l I v E R ySee Transportation Damage and Claims section located in this manual D A n G E R SAfEty pRoCEDuRES AnD pRECAutIonSw A R n I n G C A u t I o nwEIGht SItE InStAllAtIonDIMEnSIonS h x W x D IMPROPER INSTALLATION ALTERATION, ADJUSTMENTInStAllAtIon REQuIREMEntS InstallationTO PREVENT PERSONAL INJURY USE CAUTION WHEN MOVING OR lEvElInGGAS PRESSURE CHART Gas Supply & InstallationGAS SpECIfICAtIonS CONNECTING TO THE WRONG GAS SUPPLY COULD RESULT IN FIRE ORInstallation for Propane Burning Appliances Ga s Supply & InstallationGAS REQuIREMEntS GAS ConnECtIonlEAk tEStInG Ga s Supply & InstallationGAS ConnECtIon foR ovEnS on CAStERS nEvER uSE An opEn flAME to lEAk tEStELE CTR I C AL CONNECTION ENSURE POWER SOURCE MATCHES VOLTAGE STAMPED ON APPLIANCE NAMEPLATEDAnGER DAnGERvEntIlAtIon hooDS v E n t I l A t I o nDIRECt vEntInG D A n G E RSTACKING INSTRUCTIONS StACkInG kItNote Actual unit may be different than shownStACkInG, GAS pluMbInG & fluE IntERConnECt ASSEMBLY INSTRUCTIONSI nstal latio n ASC-4G Gas Convection Oven - Electronic ControlI nstal latio n ovEn StAnD ASSEMblyASC-4G Gas Convection Oven - Electronic Control DESCRIptIonDO NOT touch any electrical switches Extinguish any open ﬂame uSER SAfEty InfoRMAtIonIn thE EvEnt of A powER fAIluRE O PE R ATING INSTRUCTIONSbEfoRE InItIAl uSE StARt - up opERAtIonpREhEAtInG pAn/ShElf poSItIonSE cook indicator F temperature indicator G Probe indicator 1 Preheat indicator B ready indicator C led display D up/down arrowsH Preset indicator I cook key J Probe key K time key L Preset lock key M Start/Stop key N Preset keys O cancel keyC. WHEN THE COOK PREHEAT TEMP. HAS BEEN REACHED A. Press MAIN POWER R “ON.”ELE CTRO NIC CONTROL OPERATION B. If the previous Cook Cycle is acceptable, proceed to Step CO PE R ATING INSTRUCTIONS Menu PresetsK M N P Load food inside the oven.If cooking by probe, remove probe from itsStop an Operation To run oven continuously at a SET temperatureAdding product after Start Arrow KeysCooking Guidelines Do not place anything directly on the bottom of the oven cavityChEf opERAtInG tIpS ClEAnInG AnD pREvEntIvE MAIntEnAnCE c a r e and cleaningClEAnInG AGEntS ClEAnInG MAtERIAlSCLEAN THE OVEN ON A DAILY BASIS DISConnECt unIt fRoM powER SouRCE bEfoRE ClEAnInG oR SERvICInGAT NO TIME SHOULD THE INTERIOR OR EXTERIOR BE STEAM CLEANED HOSED DOWN, OR FLOODED WITH WATER OR LIQUID SOLUTION OFs e rvi c e Errorto test probe and air sensor CodeASC-4G Gas Convection Oven - Electronic Control serviceDESCRIPTION DESCRIPTIONDISConnECt unIt fRoM powER SouRCE bEfoRE ClEAnInG oR SERvICInG interior oven compartmentD A n G E R DAnGERs e rvi c e Leg AssemblyASC-4G Gas Convection Oven - Electronic Control DESCRIPTIONSwitches/Thermostats/Timers Parts listdescription exteriorASC-4G Gas Convection Oven - Electronic Control TRANSPORTATION DAMAGE and CLAIMS LIMITED WARRANTYVoltage Purchased From

service

DESCRIPTION

BK-34648

BS-33554