|
|
|
|
| Troubleshooting | |
Troubleshooting the Rider |
|
|
|
| ||
|
|
|
|
| ||
| PROBLEM | LOOK FOR |
|
| REMEDY | ||
| Ground speed levers not in | Lock ground speed levers in START/ PARK positions. | ||||
| START/PARK positions. |
|
|
| ||
| PTO (electric clutch) switch | Place in OFF position. | ||||
| in ON position. |
|
|
| ||
| Out of fuel. |
| If engine is hot, allow it to cool, then refill the fuel tank. | |||
| Parking brake disengaged. | Engage parking brake. | ||||
| Fuel valve closed (if |
| Open fuel valve. | |||
| equipped). |
|
|
| ||
| Engine flooded. |
| Open the choke. | |||
| Gas is old or stale. |
| Drain fuel and replace with fresh fuel. | |||
Engine will not turnover | Battery terminals require |
| Clean the battery terminals. | |||
or start. | cleaning. |
|
|
|
| |
| Battery discharged or dead. | Recharge or replace. | ||||
| Wiring loose or broken. |
| See authorized service dealer. | |||
|
| Reproduction | ||||
| Solenoid or starter motor |
| See autho ized service dealer. | |||
| faulty. |
|
|
|
| |
| Safety interlock switch not | See auth ized serv ce dealer. | ||||
| working. |
|
|
|
| |
| Spark plug(s) faulty, fouled | Clean and gap or replace. (See engine manual.) | ||||
| or incorrectly gapped. | for | ||||
| Water in fuel. |
| Drain f | el and refill with fresh fuel. | ||
| Circuit breaker bl wn. |
| See a | thorized service dealer. | ||
| Fuel mixture too rich. |
| Clean air filter. Check the choke. | |||
Engine starts hard or runs | Spark plug faulty, fouled, | r | Clean and gap or replace. (See engine manual.) | |||
poorly. | incorrectly gapped. |
|
|
| ||
| Not |
|
| |||
| Fuel filter dirty. |
| Replace fuel filter. | |||
Engine knocks. | Low oil level. |
| Check/add oil as required. | |||
Using wrong grade oil. |
| See engine manual. | ||||
|
| |||||
Excessive oil | Engine running too hot. |
| See engine fins, blower screen, and air cleaner. | |||
Using wrong grade oil. |
| See engine manual. | ||||
consumption. |
|
|
|
|
| |
Too much oil in crankcase. | Drain excess oil. | |||||
| ||||||
| Dirty air filter. |
| Replace air filter. (See engine manual.) | |||
Engine exhaust is black. | Engine choke control is in |
| Open choke control. | |||
| closed position. |
|
|
| ||
Engine runs, but rider will | Transmission(s) disengaged. | Unlock roll release rod(s). | ||||
not drive. |
|
|
|
|
| |
Belt is broken. |
| See authorized service dealer. | ||||
|
| |||||
| Drive belt slips. |
| See authorized service dealer. | |||
| Brake is not fully released. | See authorized service dealer. | ||||
| Internal transmission |
| See authorized service dealer. | |||
| problem. |
|
|
|
| |
en | 27 |
|