Manuals / Char-Broil / Kitchen Appliance / Convection Oven

Char-Broil 463269411 manual 1/4-20x1/2” screw 7mm lock washer

Models: 463269411

1 36

Download 36 pages 52.98 Kb

Page 21

Image 21

Attach left side panels to bottom shelf using three 1/4-20x1/2”screws, 7mm lock washers.

Only left side panel shown for assmebly, install right side panel in the same way.

1/4-20x1/2” screw 7mm lock washer

Left side panel

Make sure side panels are pushed as far to the rear of bottom shelf as possible before fully tightening screws.

Attach swing panel to top shelf using four #8-32x3/8”screws, 4mm lock washers.

Swing panel

Top shelf

#8-32x3/8” screw

4mm lock washer

Page 21

Image 21

Char-Broil 463269411 manual 1/4-20x1/2” screw 7mm lock washer

Contents

Please call Estimated assembly time 30-40 minutesSerial Number Date PurchasedTABLE OF CONTENTS INSTALLER/ASSEMBLERSafety Symbols DANGERInstallation Safety Precautions CALIFORNIA PROPOSITIONWash your hands after handling this product Never fill a cylinder beyond 80% full USE AND CARELP Cylinder Removal, Transport and Storage LP Liquefied Petroleum GasFor your safety Leak test new and exchanged LP cylinders BEFORE connecting to grillLP Cylinder Exchange LP Cylinder Leak TestOutdoor gas appliance is not intended to be installed in or on an RV Outdoor gas appliance is not intended to be installed in or on a boatLeak Testing Valves, Hose and Regulator Do not use grill until leak-testedFor Safe Use of Your Grill and to Avoid Serious Injury Safety TipsDo not let children operate or play near grill Do not block holes in sides or back of grillGeneral Grill Cleaning Turn controls and gas source or tank OFF when not in useIgnitor Lighting continued Match-LightingStoring Your Grill Cleaning the Burner AssemblyVERY IMPORTANT Burner tubes must reengage valve 1. Turn gas OFF at control knobs and LP cylinderBulb Specification Bulb Replacement3. Turn the light switch to “ON” ˙ Keep any electrical supply cord away from any heated surfaceCleaning the Lens Do not use this appliance if the circuit does not have GFI protectionDo not plug this appliance into an indoor circuit SCOPE OF COVERAGE LIMITED WARRANTYPERIOD OF COVERAGE TYPE OF FAILURE COVERAGEDescription PARTS LISTDescription NOT PicturedJ J J I I I D K K K K X E PARTS DIAGRAM GA MMM C B OOO U U U UFront ASSEMBLY OF LEFT CARTLocking caster Fixed caster Bottom shelf1/4-20x1/2” screw 1/4-20x1/2” screw 7mm lock washer#10-24x3/8” screw NOTE MAKE SURE THAT THE FRONT BRACE IS MOUNTED AS ILLUSTRATED BELOWInside shelf Shelf bracketBack panel 1/4-20x1/2” 7mm lock screw washerpanel Drawer frame Drawer frameDrawer front panel #10-24x3/8” ScrewFront ASSEMBLY OF RIGHT CARTLocking caster Fixed caster Bottom shelf1/4-20x1/2” screw 7mm lock washer Top shelf Swing panel 7mm lock washer 1/4-20x1/2” screw NOTE MAKE SURE THAT THE FRONT BRACE IS MOUNTED AS ILLUSTRATED BELOWLeft side panel 5mm LockBack panel Front door panelRear ASSEMBLY OF MIDDLE CARTAttach side panels to bottom shelf using three FrontBack of the panel Temperature gauge Temperature gauge stem Control panelAdapter Connect Adapter wire harness and Light wire harnessLower back panel Inside Light wire harness Adapter wire harnessInsert front brace under control panel and between cart side panels Secure using two #8x3/8” self-tapping screws each sidetwo #8x3/8” self-tapping screws on each side Upper back panelFront brace self-tapping screwPage keeping both flat walls emitters must be placedflare-up Note Some parts omitted forHeat diffuser clarity of illustrationGrease tray during use, transport, and storageCylinder screw at rear of cart Always keep LP cylinders in upright positionPrevention/Solution TroubleshootingProblem GAS ISSUESProblem Troubleshooting continuedPrevention/Solution AUTO-CLEANProblem Ignition Troubleshooting - Electronic IgnitionCheck Procedure Prevention/SolutionP.O. Box Columbus, GA Warranty Registration Department