Manuals
/
Char-Broil
/
Kitchen Appliance
/
Convection Oven
Char-Broil
463269411 manual Warranty Registration Department, P.O. Box Columbus, GA
Models:
463269411
1
35
36
36
Download
36 pages
52.98 Kb
29
30
31
32
33
34
35
36
<
>
Troubleshooting
Specifications
Install
Parts list
Parts Diagram G
Warranty
Leak test new and exchanged LP cylinders BEFORE connecting to grill
Problem
If you have questions or need assistance during assembly
Check Procedure
Page 35
Image 35
Warranty Registration Department
P.O. Box 1240
Columbus, GA
31902-1240
35
Page 34
Page 36
Page 35
Image 35
Page 34
Page 36
Contents
Date Purchased
Estimated assembly time 30-40 minutes
Please call
Serial Number
DANGER
INSTALLER/ASSEMBLER
TABLE OF CONTENTS
Safety Symbols
Wash your hands after handling this product
Installation Safety Precautions
CALIFORNIA PROPOSITION
LP Liquefied Petroleum Gas
USE AND CARE
Never fill a cylinder beyond 80% full
LP Cylinder Removal, Transport and Storage
LP Cylinder Leak Test
Leak test new and exchanged LP cylinders BEFORE connecting to grill
For your safety
LP Cylinder Exchange
Do not use grill until leak-tested
Outdoor gas appliance is not intended to be installed in or on a boat
Outdoor gas appliance is not intended to be installed in or on an RV
Leak Testing Valves, Hose and Regulator
Do not block holes in sides or back of grill
Safety Tips
For Safe Use of Your Grill and to Avoid Serious Injury
Do not let children operate or play near grill
Match-Lighting
Turn controls and gas source or tank OFF when not in use
General Grill Cleaning
Ignitor Lighting continued
1. Turn gas OFF at control knobs and LP cylinder
Cleaning the Burner Assembly
Storing Your Grill
VERY IMPORTANT Burner tubes must reengage valve
˙ Keep any electrical supply cord away from any heated surface
Bulb Replacement
Bulb Specification
3. Turn the light switch to “ON”
Do not plug this appliance into an indoor circuit
Cleaning the Lens
Do not use this appliance if the circuit does not have GFI protection
TYPE OF FAILURE COVERAGE
LIMITED WARRANTY
SCOPE OF COVERAGE
PERIOD OF COVERAGE
NOT Pictured
PARTS LIST
Description
Description
U U U U
PARTS DIAGRAM G
J J J I I I D K K K K X E
A MMM C B OOO
Bottom shelf
ASSEMBLY OF LEFT CART
Front
Locking caster Fixed caster
1/4-20x1/2” screw
1/4-20x1/2” screw 7mm lock washer
Shelf bracket
NOTE MAKE SURE THAT THE FRONT BRACE IS MOUNTED AS ILLUSTRATED BELOW
#10-24x3/8” screw
Inside shelf
panel
Back panel
1/4-20x1/2” 7mm lock screw washer
#10-24x3/8” Screw
Drawer frame
Drawer frame
Drawer front panel
Bottom shelf
ASSEMBLY OF RIGHT CART
Front
Locking caster Fixed caster
1/4-20x1/2” screw 7mm lock washer
5mm Lock
NOTE MAKE SURE THAT THE FRONT BRACE IS MOUNTED AS ILLUSTRATED BELOW
Top shelf Swing panel 7mm lock washer 1/4-20x1/2” screw
Left side panel
Back panel
Front door panel
Front
ASSEMBLY OF MIDDLE CART
Rear
Attach side panels to bottom shelf using three
Back of the panel
Temperature gauge Temperature gauge stem Control panel
Light wire harness Adapter wire harness
Connect Adapter wire harness and Light wire harness
Adapter
Lower back panel Inside
Upper back panel
Secure using two #8x3/8” self-tapping screws each side
Insert front brace under control panel and between cart side panels
two #8x3/8” self-tapping screws on each side
Front brace
self-tapping screw
Page
Note Some parts omitted forHeat diffuser clarity of illustration
emitters must be placed
keeping both flat walls
flare-up
Always keep LP cylinders in upright position
during use, transport, and storage
Grease tray
Cylinder screw at rear of cart
GAS ISSUES
Troubleshooting
Prevention/Solution
Problem
AUTO-CLEAN
Troubleshooting continued
Problem
Prevention/Solution
Prevention/Solution
Troubleshooting - Electronic Ignition
Problem Ignition
Check Procedure
P.O. Box Columbus, GA
Warranty Registration Department