Coleman 7700 LP Gas Series, 7700 Series

ÖÖAssemble the Electrode

Wires and the Battery to

the Electrode Module.

Step

22-A Electrode Module

Igniter Button Wires

(Note: Large Tabs)

9-Volt Battery

TEST THE IGNITER:

A SPARK SHOULD APPEAR AT

ELECTRODE TIP.

IF THE SPARK DOES NOT

APPEAR:

-CHECK THE WIRE

CONNECTIONS TO THE

MODULE.

-CHECK PROPER

ASSEMBLY OF FRESH

9-VOLT BATTERY.

Back Burner

Electrode Wire

22-A. Firmly push the Electrode Wires into the Electrode Module.

ÖÖAssemble the 9-Volt Battery to the Electrode Module.

ÖÖNOTE: The polarity is marked on the Electrode Module.

Contents

Main Gas Barbecue Use, Care & Assembly Manual With Grill Lighting Instructions 7700 LP Gas Series ASSEMBLER/INSTALLER: CONSUMER/USER: Contents General Safety Information 2 General Installation 8 56 9a 7 Electrical Attachments Fuel Connections Other Than Portable L.P. Cylinders Fuel Connections Other Than Portable L.P. Cylinders Portable L.P. Gas Barbecue Cylinders Cylinder Specifications L.P. Gas Cylinder L.P. Gas Cylinder Hose and Regulator Transporting the Cylinder Take these instructions to the L.P. gas dealer. CGA-510 POL TYPE 1 Transporting the Cylinder Filling and Purging Type 1 L.P. Gas Cylinders Purging and Evacuating Devices for L.P. Gas Cylinders with Type 1 Cylinder Valves Filling and Purging Type 1 L.P. Gas Cylinders Assembly/Set up NOTE: Use a large piece of cardboard or a ground NOTE: The base pieces are assembled up-side- Note: Arrange the Center Base so the Grill Label is positioned as shown. 1-A 1-B Carefully turn the assembly Engage the Locking 2-B 2-A NOTE: On some Assemble one Rectangle Assemble two small door 5-A 4-C4-B Assemble two magnets to the Cart Base using two Assemble the Cart Spacer NOTE: The Cart Spacer is assembled with 7-D 8-B Assemble the Sliding Door 9-A 9-B Install Rear Center Panel. NOTE: The Rear Panels Align the square 9-B Install Four Door Magnets. Open the door to complete Install Rear Panels. Page Fasten the Firebox to the 13-A 13-B LOOSELYfasten the Firebox to the NOTE: You will tighten these screws Page Assemble Right Side 15-A 15-B 15-C 15-D Page Assemble Left Fryer 17-A 17-B 17-C 17-D Assemble the Fuel Hose 18-A IMPORTANT! Assemble the Electrode Assemble the Grease Pan 19-A 19-B NOTE: To attach the Fryer Grease Pan, raise the Pan slightly above the Page Page Page Fasten the Rear Trim Plate NOTE: On some models, 23-A NOTE: Route 23-C Page Page Page Assemble two Grease Cup 28-A 29-B Install the Grease Pan. Install two Grease Cups. 29-A After the Grease Cups are installed, push the Grease Fasten one Door Handle to NOTE: M4 x 5mm Screws Install the Sliding Drawer 30-A 30-B NOTE 32-A Install the Short Spit Rod into Place Slip Collar on Firebox Wall. Make sure Push Set Collar against the Slip Collar, provide 32-C Install the Long Spit Rod into 33-A Place Slip Collar on Firebox Wall. Make sure Push Set Collar against the Slip Collar, provide Page Attach an LP Cylinder to the 35-A 35-B 35-C IMPORTANT! WARNING: Attach a NATURALGAS Connecting Type 1 L.P. Gas Cylinders Leak Testing Leak Testing Fixing A Fuel Leak How to Check for Leaks Fixing A Fuel Leak Start-Up Check List Control Knobs for Main Cooking Area Igniter Switch JKH REPRESENTATIVE ILLUSTRATION Lighting Main Burners Shutting Off the Grill Lighting Rotisserie Burner Igniter Lighting Fryer Burner Lighting Grilling Tips and Hints In Case of Grease Fire Follow These Steps: Note: General Use and Correct Burner Flames Cleaning the Venturi Note: REPRESENTATIVE ILLUSTRATION Cooking Methods Side Fryer Cooking Methods Moving and Storage Troubleshooting REPRESENTATIVE ILLUSTRATION Orifices Valves For Your Additional Safety Troubleshooting Regulator Nipple with Excess Flow Valve IMPORTANT! WICHITA ,KS 67201 PO BOX 2931 ATTN: DEPT 586 Coleman Grill Warranty Registration Card CONGRATULATIONS ON YOUR NEW COLEMAN GRILL PURCHASE! Number of kids in household under 18 years of age: 18 Which best describes your family income? 13 2. Mrs. 3. Ms. 4. Miss. Page Page Page Coleman Gas Barbecue Grill Limited Warranty Warranty