TROUBLESHOOTING TABLE
WARNING: Always stop unit and disconnect spark plug before perform- ing any of the recommended remedies betow other than remedies that re- quire operation of the unit.
TROUBLECAUSEREMEDY
Engine wiII not start.
1.Ignition switch off
2.Engine flooded.
3.Fuel tank empty
4.Spark piug not firing.
5.Fuel not reaching carburetor.
1. | Move | Ignition | switch | to ON. | |||
2. | See "Difficu{t | Starting" | in | Operation | |||
| section |
|
|
|
|
|
|
3. | Fil_tank with correct | fuel | mixture. | ||||
4. | InstaII | new | spark | plug |
| ||
5. | Check | for | dirty fuel filter; | replace. | |||
| Check | for | kinked | or split | fuel line; | ||
| repair | or replace. |
|
|
| ||
| 6. | Compression |
| low | |||
Engine witl not | t. | Carburetor | requires | ||||
idle properly |
| adjustment. |
|
| |||
| 2. | Crankshaft | seals worn. | ||||
| 3. | Compression |
| low. | |||
Engine will not | t. | Air filter | dirty. |
| |||
accelerete, | 2 | Spark | plug | fouled | |||
_ackspower, or |
|
|
|
|
|
| |
dies under a | 3. | Carburetor | requires | ||||
Ioad. | |||||||
| adjustment. |
|
| ||||
|
|
|
| ||||
| 4. | Carbon |
| build | up | ||
| 5. | Compression |
| low. | |||
Engine smokes | 1. | Choke | partially | on. | |||
excessively. | 2. | Fuel mixture | incorrect. | ||||
| 3. Air filter | dirty. |
| ||||
| 4. Carburetor requires | ||||||
|
| adjustment. |
|
| |||
Engine runs hot 1. Fuel mixture incorrect.
2.Spark plug incorrect
3.Carburetor requires adjustment
6. Contact Sears Service. |
1.See Service and Adjustments section.
2.Contact Sears Service.
3.Contact Sears Service.
t | Clean | or | replace | air fiIter | |
2 | Clean | or | replace | spark pIug | |
| and |
| |||
3 | See | Service and | Adjustments section. | ||
4 Contact Sears Service.
5 Contact Sears Service.
1.Adjust choke.
2.Empty fuel tank and refill with correct fueI mixture
3.Clean or replace ag filter.
4.See Service and Adjustments section.
t See "Fueling Engine".
2 Replace with correct spark plug.
3 See Service and Adjustments section
4 Contact Sears Service.
YOUR WARRANTY RIGHTS AND OBLIGATIONS: The U. S. Environ- mental Protection Agency and Sears, Roebuck and Co., U.S.A., are pleased to explain the emissions control sys- tem warranty on your lawn and garden equipment engine. Att new utility and Iawn and garden equipment engines must be designed, buitt, and equipped to meet the stringent
ods of time listed below provided there has been no abuse, neglect, or im- proper maintenance of your tawn and garden equipment engine. Your emis- sion control system includes parts such as the carburetor and the ignition system. Where a warrantable condition exits, Sears witt repair your tawn and garden equipment engine at no cost to you. Expenses covered under warran- ty include diagnosis, parts and labor,
MANUFACTURER'S WARRANTY
COVERAGE: tf any emissions related
