TROUBLESHOOTING CHART:
See appropriate section in manual unless directed to Sears service center
P,OBLEM...................- | ICAUSE | __CORRECT,ON | |||||||||
Will not start | 1 | Out | of fuel. |
| 1 | Fill fuel | tank, |
|
| ||
| 2 | Engine | not | "CHOKED" properly. | 2 | See "TO START ENGINE" | in | ||||
|
|
|
|
|
|
| Operation | section, |
| ||
| 3 | Engine | flooded° | 3 | Wait several | minutes before | |||||
|
|
|
|
|
|
| attempting | to start,. |
| ||
| 4 | Bad | spark | plug. | 4 | Replace |
| spark plug. |
| ||
| 5 | Didy | air filter_ | 5 | Clean!replace | air filter. |
| ||||
| 6 | Dirty | fuel filter. | 6 | Replace |
| fuel | filter_ |
| ||
| 7 | Water | in fuel. | 7 | Empty fuel tank and carburetor, | ||||||
|
|
|
|
|
|
| refill tank with fresh gasoline and | ||||
|
|
|
|
|
|
| replace | fuel filter, |
| ||
| 8 | Loose | or damaged wiring. | 8 | Check allwiring. |
| |||||
| 9 | Carburetor | out of adjustment, | 9 | See "To Adjust Carburetor" | in | |||||
|
|
|
|
|
|
| Service | and | Adjustments | section° | |
| I0 | Engine | valves out of adjustmenL | 10 | Contact | a Sears or other | qualified | ||||
|
|
|
|
|
|
| service | center. |
|
Hard to start
Engine will not turn over
1 | Dirty air filter. |
|
|
| 1 | Clean!replace | air filter° |
|
| |||||||
2 | Bad spark | plug, |
| 2 | Replace | spark | plug, |
|
|
| ||||||
3 | Weak | or dead | battery. | 3 | Recharge | or replace | battery. | |||||||||
4 | Dirty fuel | filter. |
|
| 4 | Replace | fuel filter. |
|
|
| ||||||
5 | Stale | or | dirty | fuelo |
| 5 | Empty fuel tank and refill tank with | |||||||||
|
|
|
|
|
|
|
|
| fresh, | clean gasoline. |
|
|
| |||
6 | Loose or damaged wiring. | 6 | Check | all wiring_ |
|
|
| |||||||||
7 | Carburetor out of adjustment. | 7 | See "To Adjust | Carburetor" | in | |||||||||||
|
|
|
|
|
|
|
|
| Service | and Adjustments | section. | |||||
B | Engine valves |
| out of adjustment, | 8 | Contact | a Sears or other | qualified | |||||||||
|
|
|
|
|
|
|
|
| service |
| center. |
|
|
|
| |
1 | Clutch/brake | pedal | not depressed. | 1 | Depress | clutch!brake | pedal. | |||||||||
2 | Attachment | clutch | is engaged. | 2 | Disengage | attachment |
| clutch. | ||||||||
3 | Weak | or dead | battery. | 3 | Recharge | or replace | battery,, | |||||||||
4 | Blown | fuse. |
|
|
| 4 | Replace | fuse. |
|
|
|
| ||||
5 | Corroded |
| battery terminals° | 5 | Clean | battery | terminals. |
|
| |||||||
6 | Loose | or damaged | wiring. | 6 | Check | all wiring. |
|
|
| |||||||
7 | Faulty | ignition |
| switch. | 7 | Check/replace | ignition | switch. | ||||||||
8 | Faulty | solenoid | or starter. | 8 | Check/replace | solenoid | or starter. | |||||||||
9 | Faulty | operator | presence | 9 | Contact | a Sears or otl_er qualified | ||||||||||
| swttch(es)_ |
|
|
|
|
| service |
| center,, |
|
|
|
32