Manuals / Dixon / Lawn and Garden / Lawn Mower

Dixon ZTR 5422, ZTR 5502 manual Dixon and ZTR are registered trademarks of Dixon Industries, Inc

Models: ZTR 5601 ZTR 5502 ZTR 5422

1 72

Page 72

WARNING: The Engine Exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm.

® Dixon and ZTR are registered trademarks of Dixon Industries, Inc.

DIXON INDUSTRIES, INC. A BLOUNT COM PAN Y AIRPORT INDUSTRIAL PARK PO BOX 1569 COFFEYVILLEKS 673370945 3162512000 FAX 316 251 4117

Part No. 8965

September 1995

Page 72

Image 72

Dixon ZTR 5422, ZTR 5502, ZTR 5601 manual Dixon and ZTR are registered trademarks of Dixon Industries, Inc

Contents

Page IMPORTANT - READ CAREFULLY INDEX SeptemberSAFETY The most common causes of injury to the operator or bystanderTIP-OVER SAFETY SAFETY SYMBOLSFollow recommended safety precautions and safe operating practices serious injury or death GENERAL OPERATIONSAFETY SLOPE OPERATIONSAFETY CHILDRENSAFETY SERVICEDIXON LIMITED WARRANTY POLICY -- HYDRO-GEAR MODELS 3. Battery warranty Limited to 90 days from date of purchase6. The following items are noLcovered by this warranty policy b Routine maintenance or adjustmentsSPECIFICATIONS SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICEModel ZTR SPECIFICATIONS SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICEModel ZTR X 5 smooth profileSPECIFICATIONS Model ZTRSEAT ADJUSTMENT INSTRUCTIONS CONTROLS PageCONTROLS CAUTION Engage parking brake before starting enginePARKING BRAKE TO SET PARKING BRAKECONTROLS TO GO FORWARDTO GO BACKWARD TURNINGCONTROLS Protection of the electrical system is by 115 amp circuit breakerOPERATION INSTRUCTIONS TESTING OF SAFETY INTERLOCK SYSTEMS BLADE DRIVE SWITCH TEST 5000 SeriesOPERATION INSTRUCTIONS OPERATION INSTRUCTIONS 1 . Push choke control lever fully forward1. Move throttle control lever to 1/4 to 1/2 setting Always turn engine off when leaving mowerOPERATION INSTRUCTIONS OPERATION INSTRUCTIONS MOWING WITH A MULCHING ATTACHMENTOPERATION INSTRUCTIONS MOWING WITH A GRASS CATCHER ATTACHMENT6. Maintain Sharp Blades Throughout The Cutting Season Be sure that deflector is properly installed on the discharge chute OPERATION INSTRUCTIONSSIDE DISCHARGE OF THE CLIPPINGS 5. Maintain Sharp Blades Throughout The Cutting SeasonOPERATION INSTRUCTIONS DECK ROLLERSPage CARE AND MAINTENANCE - 5000 SERIES MODELS MAINTENANCE SCHEDULEBefore performing any maintenance, shut off engine, allow to cool CARE AND MAINTENANCE - 5000 SERIES MODELS CUTTER BLADE MAINTENANCEWear heavy, thick gloves when holding onto cutter blade avoid the sharp edge of the bladeCARE AND MAINTENANCE - 5000 SERIES MODELS BELT TENSIONPeriodically inspect both belt and idler systems ENGINE TO MOWER DECK BELTCARE AND MAINTENANCE - 5000 SERIES MODELS FUEL SHUT OFF VALVELUBRICATION CARE AND MAINTENANCE - 5000 SERIES MODELS 5000 SERIES REAR WHEELSCARE AND MAINTENANCE - 5000 SERIES MODELS PLEASE DISPOSE OF USED OILS AT PROPER COLLECTION CENTERSPROTECT YOUR ENVIRONMENT PROTECT YOUR INVESTMENTCARE AND MAINTENANCE - 5000 SERIES MODELS MOWER DECK INSTALLATIONCARE AND MAINTENANCE - 5000 SERIES MODELS PageCARE AND MAINTENANCE - 5000 SERIES MODELS T-BOX TO HYDROSTAT BELT ADJUSTMENTCARE AND MAINTENANCE - 5000 SERIES MODELS PARKING BRAKE CABLE ADJUSTMENTCARE AND MAINTENANCE - 5000 SERIES MODELS Swing upper control levers out into the neutral slotsCARE AND MAINTENANCE - 5000 SERIES MODELS FORWARD TRAVEL SPEED ADJUSTMENTSDO NOT SPEED UP THE SLOW SIDE, AS OVER STROKING OF THE HYDROSTAT COULD RESULT IN DAMAGE TO THE UNITCARE AND MAINTENANCE - 5000 SERIES MODELS PROCEDURE FOR ELECTRIC CLUTCH ADJUSTMENTB. OHMS TEST CARE AND MAINTENANCE - 5000 SERIES MODELS HYDROSTATIC TRANSMISSION OIL AND FILTER SERVICECARE AND MAINTENANCE - 5000 SERIES MODELS CLEANING THE MOWER SERIAL NUMBERS WARRANTY PARTS/SERVICEWHEELS AND TIRES Model ZTR Models ZTR 5502 & ZTR ELECTRICAL SYSTEMS STANDARD SERVICE PARTS LIST MODEL ZTRMODEL ZTR MODEL ZTRSTANDARD SERVICE PARTS LIST KOHLER AIR AND OIL FILTER PART NUMBERSKOHLER ANTI-ICING KIT TROUBLESHOOTING MOWER CUT QUALITYTROUBLESHOOTING DRIVE SYSTEMSITUATION CAUSESTROUBLESHOOTING Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page OWNER INFORMATION PURCHASED FROM Name AddressFAX 316 251 Page Page Page Page Page Dixon and ZTR are registered trademarks of Dixon Industries, Inc