Contents
E-mail service@frymaster.com
8196383
YFPRE1817E
Installation & Operation Manual
DANGER
NOTICE TO U.S. CUSTOMERS
NOTICE TO OWNERS OF UNITS EQUIPPED WITH COMPUTERS U.S
CANADA
DANGER
DANGER
DANGER
DANGER
CHAPTER 6 Operator Troubleshooting
TABLE OF CONTENTS
CHAPTER 2 Installation Instructions
CHAPTER 5 Preventive Maintenance
DANGER
YFPRE18E ELECTRIC FRYERS CHAPTER 1 INTRODUCTION
1.2 Safety Information
1.1 General
1.5 Definitions
1.4 Installation, Operating, and Service Personnel
QUALIFIED INSTALLATION PERSONNEL
QUALIFIED SERVICE PERSONNEL
RETAIN AND STORE THIS MANUAL IN A SAFE PLACE FOR FUTURE USE
1.6 Shipping Damage Claim Procedure
1.7 Service Information
What to do if your equipment arrives damaged
YFPRE18E ELECTRIC FRYER CHAPTER 2 INSTALLATION INSTRUCTIONS
In the event of a power failure, the fryers will automatically shut down. If this occurs, turn the power switch OFF. Do not attempt to start the fryers until power is restored
Three 3 Phase Requirements
2.2 Power Requirements
2.3 After Fryers Are Positioned At the Frying Station DANGER
2. Close fryer drain-valves and fill frypot with water to the bottom oil level line
Control Panel
YFPRE18E ELECTRIC FRYER CHAPTER 3 OPERATING INSTRUCTIONS
Basket Hanger Lift Rod Tilt Housing Top Cap Bezel
Power Switch
Shutdown
Setup
3.2 Controllers
Page
YFPRE18E ELECTRIC FRYER CHAPTER 4 BUILT-IN FILTRATION
4.2.1 Assembling the Filter
4. 1 General
4.2 Filtration Preparation
YFPRE18E ELECTRIC FRYER CHAPTER 4 BUILT-IN FILTRATION
Assemble the filter as follows
The filter pan is shown partially inserted under the fryer
4.3 Daily Filtration Operation
4.4 Operating the Filter
Prior to filtering, skim any large debris from oil in frypot
DANGER
5. After ensuring the filter pan is correctly positioned under the drain tube and the pan is properly connected, open the drain valve by pulling the blue handle to the left. Drain only one frypot at a time
Page
YFPRE18E ELECTRIC FRYER CHAPTER 5 PREVENTATIVE MAINTENANCE
This appliance should be inspected and adjusted periodically by qualified service personnel as part of a regular kitchen maintenance program
Check filtration system integrity as follows
Before calling a service agent or the Frymaster HOTLINE
YFPRE18E ELECTRIC FRYER CHAPTER 6 OPERATOR TROUBLESHOOTING
6.2 Troubleshooting 6.2.1 Controller and Heating Problems
Problem
Probable Causes
Corrective Action
Corrective Action
Problem
Problem
Probable Causes
Blockage in filter pan suction tube
Problem
Probable Causes
Corrective Action
THIS PAGE INTENTIONALLY LEFT BLANK
Tech Support
SERVICE HOTLINE
Frymaster, L.L.C., 8700 Line Avenue, Shreveport, Louisiana
FAX Parts
