Contents
8196383
YFPRE1817E
Installation & Operation Manual
E-mail service@frymaster.com
NOTICE TO U.S. CUSTOMERS
NOTICE TO OWNERS OF UNITS EQUIPPED WITH COMPUTERS U.S
CANADA
DANGER
DANGER
DANGER
DANGER
DANGER
TABLE OF CONTENTS
CHAPTER 2 Installation Instructions
CHAPTER 5 Preventive Maintenance
CHAPTER 6 Operator Troubleshooting
YFPRE18E ELECTRIC FRYERS CHAPTER 1 INTRODUCTION
1.2 Safety Information
1.1 General
DANGER
1.4 Installation, Operating, and Service Personnel
QUALIFIED INSTALLATION PERSONNEL
QUALIFIED SERVICE PERSONNEL
1.5 Definitions
1.6 Shipping Damage Claim Procedure
1.7 Service Information
What to do if your equipment arrives damaged
RETAIN AND STORE THIS MANUAL IN A SAFE PLACE FOR FUTURE USE
YFPRE18E ELECTRIC FRYER CHAPTER 2 INSTALLATION INSTRUCTIONS
In the event of a power failure, the fryers will automatically shut down. If this occurs, turn the power switch OFF. Do not attempt to start the fryers until power is restored
2.3 After Fryers Are Positioned At the Frying Station DANGER
2.2 Power Requirements
Three 3 Phase Requirements
2. Close fryer drain-valves and fill frypot with water to the bottom oil level line
YFPRE18E ELECTRIC FRYER CHAPTER 3 OPERATING INSTRUCTIONS
Basket Hanger Lift Rod Tilt Housing Top Cap Bezel
Power Switch
Control Panel
Setup
Shutdown
3.2 Controllers
Page
YFPRE18E ELECTRIC FRYER CHAPTER 4 BUILT-IN FILTRATION
4. 1 General
4.2 Filtration Preparation
YFPRE18E ELECTRIC FRYER CHAPTER 4 BUILT-IN FILTRATION
4.2.1 Assembling the Filter
Assemble the filter as follows
4.3 Daily Filtration Operation
The filter pan is shown partially inserted under the fryer
4.4 Operating the Filter
DANGER
Prior to filtering, skim any large debris from oil in frypot
5. After ensuring the filter pan is correctly positioned under the drain tube and the pan is properly connected, open the drain valve by pulling the blue handle to the left. Drain only one frypot at a time
Page
YFPRE18E ELECTRIC FRYER CHAPTER 5 PREVENTATIVE MAINTENANCE
This appliance should be inspected and adjusted periodically by qualified service personnel as part of a regular kitchen maintenance program
Check filtration system integrity as follows
YFPRE18E ELECTRIC FRYER CHAPTER 6 OPERATOR TROUBLESHOOTING
Before calling a service agent or the Frymaster HOTLINE
Problem
Probable Causes
Corrective Action
6.2 Troubleshooting 6.2.1 Controller and Heating Problems
Problem
Problem
Probable Causes
Corrective Action
Problem
Probable Causes
Corrective Action
Blockage in filter pan suction tube
THIS PAGE INTENTIONALLY LEFT BLANK
SERVICE HOTLINE
Frymaster, L.L.C., 8700 Line Avenue, Shreveport, Louisiana
FAX Parts
Tech Support