Brkt Regulator Mounting | Generac Power Systems 5253, 5252, 5254

				Section 9 — Exploded Views and Parts Lists
				Section 9 — Exploded Views and Parts Lists
				Air-cooled Generators
				13 & 16kW, GT-990 Regulator – Drawing No. 0F9426
	ITEM	PART NO.	QTY.	DESCRIPTION
	1	0F9285	1	CASTING, TWIN REGULATOR HOUSING
	2	0F5022	1	SOLENOID COIL, 12VDC
	3	0C4647	2	GASKET , SOLENOID
	4	0D4166	1	PLUNGER, LP REGULATOR ASSEMBLY
	5	0F8096	1	BRKT REGULATOR MOUNTING 990
	6	022145	4	WASHER FLAT 5/16-M8
	7	022129	4	WASHER LOCK 5/16-M8
	8	0F4795	8	SCREW PPHM SEMS M4-0.7 X 10
	9	045771	2	NUT HEX M8-1.25
	10	0C6606	2	BARBED STRAIGHT ½ NPT x ½
	11	042907	2	SCREW HHC M8-1.25 X 16
	12	026915A	1	NIPPLE CLOSE ¾ X 1.375 WITH VIBRA SEAL
	13	0C5761	2	LEVER, REGULATOR
	14	0C5968	2	SUPPORT, INLET SEAL
	15	0C6066	2	SEAL, INLET
	16	0C5759	2	PIN, PIVOT ARM
	17	0C5764	2	SPRING, REGULATOR
	18	070728	4	SCREW, PFHMS M3-0.5 x 5
	19	0C6069	2	GASKET, DIAPHRAGM
	20	0F9189	2	COVER, TWIN REGULATOR
	21	045764	16	SCREW, TAPTITE M4X8 BP
	22	0C6731	2	RIVET, POP .118 X .125
	23	0C6067	2	SUPPORT, DIAPHRAGM
	24	0C4706	2	DIAPHRAGM, TWIN REGULATOR
	25	0C6068	2	CAP, DIAPHRAGM SUPPORT
	26	0C4643A	2	INLET, TWIN REGULATOR 11.11 DIA.
	27	072683A	3	PLUG STD PIPE 1/8 SOCKET HEAD
	28	049226	4	WASHER, LOCK, M5
	29	0D3308	4	WASHER, FLAT M3 X 10mm O.D.
	30	051713	4	WASHER, FLAT, M5
	31	0F8979	1	SOLENOID COVER PLATE
	32	051716	4	NUT HEX M5-0.8
	33	0E9533	1	SOLENOID ADAPTER
	34	0E9534	1	ASSY, FUEL SYSTEM PLENUM
	35	0E9535	1	PLENUM GASKET

67

Image 69

Generac Power Systems 5253, 5252, 5254, 5251, 5255 owner manual Brkt Regulator Mounting

Contents

Listed Authorized Dealer Location Introduction Maintenance Post Installation Start-up AdjustmentsTroubleshooting Introduction Inside Front Cover  Warning  ‹ Standards Index  Electrical Hazards  UNPACKING/INSPECTION Protection SystemsBreaker for Bedrooms 7kW, Single Cylinder GH-410 Engine Generator Specifications ‹ 1.5.1 Generator‹ 1.5.2 Engine Fuel Requirements Recommendations System SET LEDFuel Consumption ‹ 1.8.1 BTU Flow Requirements Natural GAS Reconfiguring the Fuel System ‹ 1.9.1 7 KW, 410CC Engine‹ 1.9.2 10, 13 and 16KW, V-TWIN Engines ‹ 1.10.1 Generator Location Battery Installation Battery Requirements‹ 1.10.2 Transfer Switch 10.2.1 7, 10, 13, and 16 kW Units if equipped 10 Battery Cable Connections Battery Check Transfer Switch Operation Before Initial START-UPElectrical Checks Generator Tests Under Load Checking Automatic Operation7KW Natural GAS only ‹ 2.7.1 7 KW Units Engine Governor Adjustment ‹ 3.1.3 Manual Position ‹ 3.1.1 Auto Position Sequence of Automatic Operation Automatic Transfer OperationManual Transfer Operation ‹ 3.1.4 Choke Operation ‹ 3.4.2 Transfer Back to Utility Power Source Setting the Exercise Timer ‹ 3.6.2 High Temperature Switch ‹ 3.6.1 LOW OIL Pressure Switch‹ 3.6.3 Overcrank Approximate Crank Cycle Times Checking the Engine OIL Level ‹ 3.6.6 LOW BatteryFuses ‹ 3.6.5 RPM Sensor Failure Changing the Engine OIL ‹ 4.3.1 OIL Change Intervals‹ 4.3.2 Engine OIL Recommendations Spark Plugs ‹ 4.4.1 7, 13, and 16KW Generators‹ 4.4.2 10KW Generators Valve Clearance Battery Maintenance 11 Cooling Vent Locations Cooling System ‹ 4.11.2 Return to Service OUT of Service Procedure‹ 4.11.1 Removal from Service Corrosion Protection Be performed by the nearest Authorized Dealer Service Schedule Problem Cause Correction Troubleshooting Guide Air-cooled Generators Air-cooled Generators Air-cooled Generators Mounting Dimensions Electrical Data Engine Wiring Customer Connection Battery Charger Engine Alternator Engine Wiring Stator Electronic Voltage Regulator Manual Auto Scsm Neutral Electrical Data Electrical Data Sheet Metal PAINT/MATERIAL Code Legend Part NO. QTY. Description Air-cooled Generators Control Panel Drawing No F9695-C QTY Description Exploded Views and Parts Lists BOX Load Center Exploded Views and Parts Lists Description QTY Exploded Views and Parts Lists Washer Flat M8 5/16 Exploded Views and Parts Lists Crankcase Exploded Views and Parts Lists Intake Adapter Exploded Views and Parts Lists PIN, Piston D20 Exploded Views and Parts Lists SCREW, Taptite M6-1.0X8 Yellow Chrome Air-cooled Generators 7kW, GN-410 Engine Drawing No F9422-B ADAPTOR, Engine Exploded Views and Parts Lists ADATOR, Engine 7KW CASTING, Twin Regulator Housing 7KW Exploded Views and Parts Lists Brkt Regulator Mounting Your Warranty Rights and Obligations MANUFACTURER’S Emission Control System Warranty CoveragePURCHASER’S/OWNER’S Warranty Responsibilities Emission Related Parts Include the Following Emission Control System Warranty Generac Power Systems Standard Limited Warranty for