Manuals / Hearth and Home Technologies / Kitchen Appliance / Egg Cooker

Hearth and Home Technologies BH 105 Testing Label, BH105, exceeding -.9 in Water Column / -224Pa

Models: BH 105

1 49

Download 49 pages 25.25 Kb

Page 45

Image 45

Testing Label

BH105

Wood

WARNING: Risk of fire - Do not operate with the flue draft	ATTENTION: Risque de feu - Ne fonctionnez pas avec l'ébauche
exceeding -.9 in Water Column / -224Pa.	deconduite de cheminée excédant -.9 " colonne de l'eau / -224Pa.

Hearth & Home Technologies, Inc.

Page 45

Image 45

Hearth and Home Technologies BH 105 Testing Label, BH105, WARNING Risk of fire - Do not operate with the flue draft, Wood

Contents

SAFETY NOTICE Installation & Operating ManualThe BH 105 Pellet Boiler save these instructionsPage Parts Locations Introduction Please read this entire manual before you install and use your newSAVE THESE INSTRUCTIONS Table Of ContentsECO-CHOICE LIMITED WARRANTY WarrantyBoiler Kit Materials Refer to page AssemblyAssembly DesignFloor Protection Assembly INSTALLATION IS TO BE PERFORMED BY A QUALIFIED INSTALLERNOTE All installation clearances and restrictions must be adhered to Venting Avoid venting into alcove locations VentingVentingti g INSTALLATION IS TO BE PERFORMED BY A QUALIFIED INSTALLER Venting InstallationNOTE All installation clearances and restrictions must be adhered to Keep combustibles away from flue outletOutside Air InstallationHeat Reclaiming Ventilation System HRV NOTE The inlet cover should not be placed in anMain Wiring Installation InstallingInstallationDuct Installing Duct/AirInstallationConditioning RECOMMENDED INSTALLATION INSTRUCTIONS FOR THE PROPER InstallationEXAMPLE OF TYPICAL TANKLESS DOMESTIC HOT WATER PIPING EXAMPLES OF TYPICAL DOMESTIC HOT WATER STORAGE PIPINGSENSING BULB InstallationSHUT-OFF VALVE AIR SCOOPInstallation Power Failure / Heat Dissipation Loop Over Heat Safety ZoneA POWER FAILURE HEAT DISSIPATION LOOP EXAMPLE OF PIPING IN ACCORDANCE WITH CAN/CSA-B366.1The Control InstallationFirebox Door Fuel and Fuel Storage Fuel SpecificationsMax Temp dial OperationNOTE Pellet Boiler Outdoor Air Reset Operation Graph located on page WATER TEMPERATUREWithout the Outdoor Air Temperature Sensor Installed OperationOperation Pellet Boiler Outdoor Air Reset Operation1. Turn Mode Selector to “OFF” OperationStarting A Fire Automatically 5. Turn Feed Adjuster to #4 WATER TEMPERATURE6. Flip the Igniter Switch up into the “AUTO” position Operation9. Fill hopper with pellets and remove ashes as required Type of Fuel OperationLighting A Fire Manually Follow steps 1 through 5 of the instructions for automatic lightingOperation 11. Apply starting gel as shown in Fig.1512. Light The Starting Gel With A Match 13. Close The Doors Burnpot Cleaning MaintenanceCleano ut cover Cleaning the Burnpot Air ChamberRoutine cleaning of heat exchangers and venting is required MaintenanceWarning! Risk of Fire Ash, soot or creosote build-up may cause overheating or fireCleaning Steps MaintenanceMaintenance Combustion Blower CleaningCleaning the Tube Heat Exchangers Helpful Hints TroubleshootingFuel Cleaning Burn PotAtmospheric Conversion Stocked bh105bh105 #8 Ash base Assemblybh105 Cleanout Rod Repair Kit1-00-72210 Scraper Rod Guidebh105 #28 Feeder Assembly28.1 28.16#29 boiler Kit bh105#30 water Plate Kit #31 handle KitStocked bh105Screw, #8-18 x 1/2 Hex washer Head Self Drilling Zinc #2 Pt washer, #10-16 x 3/4 hex head TEKS 3 SdS Climaseal PlatedSpecifications BTU Input Range= 0, and 9350 to 113,900Electrical 120 VAC 60 Hz Diagram WiringPELLET BOILER WIRING DIAGRAM When current is present, will keep UPS in Power Failure Backup SupplyReady mode POWER FROM THE UPS / This plugsBH105 Testing LabelBH105 WARNING Risk of fire - Do not operate with the flue draftDate Of Service Service Record / NotesDescription Of Service Performed ByProudly Printed On 100% Recycled Paper Quick Reference Auto-Light See the section on Maintenance for more details about cleaning1 Turn Mode Selector to OFF 2 Use heat exchanger cleanout rods to clean the heat exchanger tubesSignature of Boxer

Testing Label

BH105

BH105

Wood

WARNING: Risk of fire - Do not operate with the flue draft

exceeding -.9 in Water Column / -224Pa.

Hearth & Home Technologies, Inc.