Manuals / Hearth and Home Technologies / Kitchen Appliance / Egg Cooker

Hearth and Home Technologies BH 105 manual Parts Locations

Models: BH 105

1 49

Download 49 pages 25.25 Kb

Page 3

Image 3

1-1/4” FMPT Supply

Hopper Lid

Latches

Hopper

Control Board

Control Board Cover

Temperature / Pressure Gauge

Aquastat Well

Pressure Relief Valve

Blank Cover

(Removed w/ Domestic Hot Water Option)

Manual background 1-1/4” FMPT Return

Vent Pipe

Parts Locations

Access Cover To
Hopper / Swing Plate Knob
Firebox Door	Combustion Blower
Firebox Door
Viewing Glass
Ash Door	Combustion Blower Cover
Access Cover To Secondary Ash Chamber	3/4” FMPT Boiler Drain

Page 3

Image 3

Hearth and Home Technologies BH 105 manual Parts Locations

Contents

save these instructions Installation & Operating ManualSAFETY NOTICE The BH 105 Pellet BoilerPage Parts Locations Table Of Contents Please read this entire manual before you install and use your newIntroduction SAVE THESE INSTRUCTIONSECO-CHOICE LIMITED WARRANTY WarrantyBoiler Kit Materials Refer to page AssemblyAssembly DesignFloor Protection Assembly INSTALLATION IS TO BE PERFORMED BY A QUALIFIED INSTALLERNOTE All installation clearances and restrictions must be adhered to Venting Avoid venting into alcove locations VentingVentingti g Keep combustibles away from flue outlet Venting InstallationINSTALLATION IS TO BE PERFORMED BY A QUALIFIED INSTALLER NOTE All installation clearances and restrictions must be adhered toNOTE The inlet cover should not be placed in an InstallationOutside Air Heat Reclaiming Ventilation System HRVMain Wiring Installation InstallingInstallationDuct Installing Duct/AirInstallationConditioning EXAMPLES OF TYPICAL DOMESTIC HOT WATER STORAGE PIPING InstallationRECOMMENDED INSTALLATION INSTRUCTIONS FOR THE PROPER EXAMPLE OF TYPICAL TANKLESS DOMESTIC HOT WATER PIPINGAIR SCOOP InstallationSENSING BULB SHUT-OFF VALVEInstallation EXAMPLE OF PIPING IN ACCORDANCE WITH CAN/CSA-B366.1 Over Heat Safety ZonePower Failure / Heat Dissipation Loop A POWER FAILURE HEAT DISSIPATION LOOPThe Control InstallationFirebox Door Fuel and Fuel Storage Fuel SpecificationsMax Temp dial OperationOperation WATER TEMPERATURENOTE Pellet Boiler Outdoor Air Reset Operation Graph located on page Without the Outdoor Air Temperature Sensor InstalledOperation Pellet Boiler Outdoor Air Reset Operation1. Turn Mode Selector to “OFF” OperationStarting A Fire Automatically Operation WATER TEMPERATURE5. Turn Feed Adjuster to #4 6. Flip the Igniter Switch up into the “AUTO” positionFollow steps 1 through 5 of the instructions for automatic lighting Operation9. Fill hopper with pellets and remove ashes as required Type of Fuel Lighting A Fire ManuallyOperation 11. Apply starting gel as shown in Fig.1512. Light The Starting Gel With A Match 13. Close The Doors Cleaning the Burnpot Air Chamber MaintenanceBurnpot Cleaning Cleano ut coverAsh, soot or creosote build-up may cause overheating or fire MaintenanceRoutine cleaning of heat exchangers and venting is required Warning! Risk of FireCleaning Steps MaintenanceMaintenance Combustion Blower CleaningCleaning the Tube Heat Exchangers Cleaning Burn Pot TroubleshootingHelpful Hints FuelAtmospheric Conversion Stocked bh105bh105 #8 Ash base AssemblyScraper Rod Guide Cleanout Rod Repair Kitbh105 1-00-7221028.16 #28 Feeder Assemblybh105 28.1#31 handle Kit bh105#29 boiler Kit #30 water Plate Kitwasher, #10-16 x 3/4 hex head TEKS 3 SdS Climaseal Plated bh105Stocked Screw, #8-18 x 1/2 Hex washer Head Self Drilling Zinc #2 PtSpecifications BTU Input Range= 0, and 9350 to 113,900Electrical 120 VAC 60 Hz Diagram WiringPELLET BOILER WIRING DIAGRAM POWER FROM THE UPS / This plugs Power Failure Backup SupplyWhen current is present, will keep UPS in Ready modeWARNING Risk of fire - Do not operate with the flue draft Testing LabelBH105 BH105Performed By Service Record / NotesDate Of Service Description Of ServiceProudly Printed On 100% Recycled Paper 2 Use heat exchanger cleanout rods to clean the heat exchanger tubes See the section on Maintenance for more details about cleaningQuick Reference Auto-Light 1 Turn Mode Selector to OFFSignature of Boxer