A20p, A21p, A22p
IBM Mobile Systems ThinkPad Computer Hardware Maintenance Manual
October This manual supports ThinkPad A20m, A21m, A22m
ThinkPad Dock
Second Edition October
About this manual
iv ThinkPad A20m/p, A21m/p, A22m/p
Introduction
Contents
About this manual
General descriptions
1040
Introduction
Important service information
Strategy for replacing FRUs
Diskette compatibility matrix
How to use error messages
Strategy for replacing a hard-disk drive
Safety notices multilingual translations
Safety notice
Safety notice DANGER
Algunas baterías de reserva contienen una pequeñ a cantidad de níquel y cadmio. No las desmonte, ni recargue, ni las eche al fuego o al agua ni las cortocircuite. Desé chelas tal como dispone la normativa local. Utilice só lo baterías que se encuentren en la lista de piezas. La utilizació n de una batería no apropiada puede provocar la ignició n o explosió n de la misma
La batterie contient du nickel. Ne la dé montez pas, ne l’exposez ni au feu ni à l’eau. Ne la mettez pas en court- circuit. Pour la mettre au rebut, conformez-vous à la ré glementation en vigueur. Lorsque vous remplacez la batterie, veillez à n’utiliser que les modè les cité s dans la liste de piè ces dé taché es adé quate. En effet, une batterie inapproprié e risque de prendre feu ou d’exploser
Las baterías contienen pequeñ as cantidades de níquel. No las desmonte, ni recargue, ni las eche al fuego o al agua ni las cortocircuite. Desé chelas tal como dispone la normativa local. Utilice só lo baterías que se encuentren en la lista de piezas al sustituir la batería. La utilizació n de una batería no apropiada puede provocar la ignició n o explosió n de la misma
The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100C 212F, incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result in ignition or explosion of the battery
Desé chela tal como dispone la normativa local
10 ThinkPad A20m/p, A21m/p, A22m/p
To avoid shock, do not remove the plastic cover that protects the lower part of the inverter card
12 ThinkPad A20m/p, A21m/p, A22m/p
Die Stromzufuhr muß abgeschaltet, alle Stromkabel aus der Steckdose gezogen, der Akku entfernt und alle Verbindungskabel abgenommen sein, bevor eine FRU entfernt wird
Safety information
General safety
Electrical safety
Safety inspection guide
Handling electrostatic discharge-sensitive devices
Grounding requirements
Laser compliance statement
Laser compliance statement
20 ThinkPad A20m/p, A21m/p, A22m/p
DANGER
22 ThinkPad A20m/p, A21m/p, A22m/p
Laser compliance statement
Read this first
General descriptions
What to do first
Note for warranty
The following are not covered under warranty
Product recovery program
Related service information
Service web site
Restoring the pre-installed software
To create the Service Partition SP
Creating the service partition
To create a recovery repair diskette
Reinstall the Product Recovery Program? Y/N ”
Passwords
To use the recovery repair diskette
Supervisor password
Power-on password
Hard-disk password
How to remove the power-on password
4. Select Power-On Password
How to remove the hard-disk password
5. Select Master HDP
Screen blank mode
Power management
Standby mode
Note for the APM operating system
Hibernation mode
Note for Windows NT
Note for OS/2
Checkout guide
Testing the computer
Checkout guide
Diagnostics
If an error code appears, go to “Symptom-to-FRU index” on page
3. Select Diagnostics with the arrow keys, and press Enter
Other Devices Diagnostics
Hardware Info
Power system checkout
Detecting system information with PC-Doctor
Utility
Checking the ac adapter
Checking operational charging
Checking the battery pack
Checking the backup battery
Red + Black
ThinkPad A20m/p, A21m/p and A22m/p
12.1-in. panel
Feature
Specifications
Product overview
Description
42 ThinkPad A20m/p, A21m/p, A22m/p
Feature
continued
Description
Description
Feature
ThinkPad A20m/p, A21m/p and A22m/p
A20m/p
Status indicators
indicator is off, the system is ready to
ThinkPad A20m/p, A21m/p and A22m/p
continued
FRU tests
The following table shows the test for each FRU
46 ThinkPad A20m/p, A21m/p, A22m/p
Applicable test
Fn key combinations
48 ThinkPad A20m/p, A21m/p, A22m/p
Numeric error codes
Symptom-to-FRU index
Symptom-to-FRU index
continued
50 ThinkPad A20m/p, A21m/p, A22m/p
ThinkPad A20m/p, A21m/p and A22m/p
Error messages
52 ThinkPad A20m/p, A21m/p, A22m/p
No beep symptoms
Beep symptoms
ThinkPad A20m/p, A21m/p and A22m/p
LCD-related symptoms
Intermittent problems
Undetermined problems
v Plastic to plastic
FRU replacement notices
Screw notices
90 degrees more Cross-section
Restoring the serial number of the system unit
Retaining serial numbers
Retaining the UUID
2. From the main menu, select 4. Assign UUID
Removing and replacing a FRU
Removing and replacing a FRU
1010 Battery pack
60 ThinkPad A20m/p, A21m/p, A22m/p
Note Loosen the screw
1020 DIMM
For access, remove this FRU v “1010 Battery pack” on page
but do not remove it
62 ThinkPad A20m/p, A21m/p, A22m/p
Removing and replacing a FRU
Note Loosen the screw
1030 Mini PCI adapter
For access, remove this FRU v “1010 Battery pack” on page
but do not remove it
For A20m/p, A21m/p series
For A22m/p series
v “1020 DIMM” on page v “1030 Mini PCI adapter” on page
1040 Backup battery
For access, remove these FRUs, in order v “1010 Battery pack” on page
66 ThinkPad A20m/p, A21m/p, A22m/p
1050 Hard-disk drive or RF ID adapter
Do not drop or apply any shock to the hard-disk
68 ThinkPad A20m/p, A21m/p, A22m/p
When installing Make sure that the HDD connector is firmly connected
Removing and replacing a FRU
1060 Ultrabay 2000 device
to release
70 ThinkPad A20m/p, A21m/p, A22m/p
Removing and replacing a FRU
0.392 Nm
1070 Keyboard
M2.5 × 15 mm, nylon-coated
4 kgfcm
72 ThinkPad A20m/p, A21m/p, A22m/p
continued
Removing and replacing a FRU
connector on the underside of the key then push the
v “1050 Hard-disk drive or RF ID adapter” on page
1080 Keyboard CRU insulator
For access, remove these FRUs, in order v “1010 Battery pack” on page
v “1060 Ultrabay 2000 device” on page v “1070 Keyboard” on page
1090 Hinge cover and clear sheet icon
1100 Keyboard bezel and speaker
Screw quantity
ThinkPad A20m/p, A21m/p and A22m/p
Step
Torque
1110 Microphone and speaker cable
For A20m/p and A21m/p series microphone and speaker cable
When installing Make sure that you fasten the connector firmly
For A22m/p series speaker cable
ThinkPad A20m/p, A21m/p and A22m/p
1120 Sub card
Screw quantity
ThinkPad A20m/p, A21m/p and A22m/p
Step
Torque
0.245 Nm
1130 PC Card slot assembly
M2.0 × 9.5 mm, nylon-coated
2.5 kgfcm
1140 Fan assembly
Note Step
Installation notice for A21m/p and A22m/p series
84 ThinkPad A20m/p, A21m/p, A22m/p
1150 Diskette drive
Note Step
When installing Do not press the
1160 Upper shield
1170 TV card
1180 CPU socket and CPU
v Rotate the screw head A 180 to the direction of the
When installing the CPU, do as shown in the figure
v When attach the CPU to the socket, do as shown in the step
arrow
1190 System board and RJ45/11 connector assembly
For A20m/p and A21m/p series For A22m/p series
Bottom side of the system board For A22m/p series
Thermal rubbers location
For A21m/p series Upper side of the system board
Upper side of the system board
2010 LCD assembly
Screw quantity
ThinkPad A20m/p, A21m/p and A22m/p
Step
Torque
2020 Front bezel
12.1-in. panel
14.1-in. and 15.0-in. panels
ThinkPad A20m/p, A21m/p and A22m/p
98 ThinkPad A20m/p, A21m/p, A22m/p
Removing and replacing a FRU
2030 Inverter card
12.1-in. panel
14.1-in. and 15.0-in. panels
100 ThinkPad A20m/p, A21m/p, A22m/p
2040 LCD panel
12.1-in. panel
102 ThinkPad A20m/p, A21m/p, A22m/p
continued
Removing and replacing a FRU
continued
14.1-in. and 15.0-in. panels
ThinkPad A20m/p, A21m/p and A22m/p
LCD cable in step v The LCD cable for the 15.0-in. UXGA LCD 27L0598
3010 ThinkPad Dock PCI cover
Before replacing the PCI cover
106 ThinkPad A20m/p, A21m/p, A22m/p
Bottom view
Removing and replacing a FRU
Rear
3020 ThinkPad Dock top cover
view
continued
Bottom
view
108 ThinkPad A20m/p, A21m/p, A22m/p
view, shown in the circle
v Make sure that the device release lever is seated correctly
When replacing the top cover, do the following
v Make sure that the springs placed correctly
continued
ThinkPad A20m/p, A21m/p and A22m/p
v Make sure that the release button works correctly
Removing and replacing a FRU
Locations Front view
Serial connector External-monitor connector
Rear view
Security keyhole Parallel connector Modem connector Network connector
Universal serial bus USB connector External-input-device connector
Docking connector DIMM slot Stereo headphone jack Stereo line-in jack
Bottom view
Battery pack Battery pack latches Mini PCI card slot
Diskette drive Microphone jack Infrared port Hard-disk drive
Mini PCI
Parts list A series model matrix
Model
device
1 Memory 128 MB continued
Parts list
116 ThinkPad A20m/p, A21m/p, A22m/p
Model
1 Memory 128 MB continued
ThinkPad A20m/p, A21m/p and A22m/p
Mini PCI
Model
continued
118 ThinkPad A20m/p, A21m/p, A22m/p
Mini PCI
Model
1 Memory 128 MB continued
ThinkPad A20m/p, A21m/p and A22m/p
Bay device
Model
continued
120 ThinkPad A20m/p, A21m/p, A22m/p
Mini PCI
Model
1 Memory 128 MB continued
ThinkPad A20m/p, A21m/p and A22m/p
Bay device
except Y2J
122 ThinkPad A20m/p, A21m/p, A22m/p
except Y1J
except U1J
Overall
optional FRUs
v The FRUs marked with
are also available as
Gxx, Kxx, Qxx, Txx
continued
ThinkPad A20m/p, A21m/p and A22m/p
continued
126 ThinkPad A20m/p, A21m/p, A22m/p
continued
ThinkPad A20m/p, A21m/p and A22m/p
continued
128 ThinkPad A20m/p, A21m/p, A22m/p
continued
ThinkPad A20m/p, A21m/p and A22m/p
continued
130 ThinkPad A20m/p, A21m/p, A22m/p
continued
ThinkPad A20m/p, A21m/p and A22m/p
continued
132 ThinkPad A20m/p, A21m/p, A22m/p
continued
ThinkPad A20m/p, A21m/p and A22m/p
continued
134 ThinkPad A20m/p, A21m/p, A22m/p
ThinkPad A20m/p, A21m/p and A22m/p
LCD FRUs
AC adapter
12.1-in. SVGA TFT
14.1-in. XGA TFT
ThinkPad A20m/p, A21m/p and A22m/p
Following FRUs are available for MT2628-3xx, Jxx, Pxx, Rxx
15.0-in. XGA TFT LG
15.0-in. XGA TFT SAMSUNG
Following FRUs are available for MT2628-3xx, Fxx, Jxx, Pxx, Rxx
Following FRUs are available for MT2628-Sxx and
15.0-in. SXGA+ TFT
15.0-in. UXGA TFT
Following FRUs are available for MT2629-Hxx, Uxx, Yxx
All of the keyboards listed below are CRUs customer replaceable units
Keyboard
140 ThinkPad A20m/p, A21m/p, A22m/p
Recovery CDs
For Windows 98 A22m
For Windows 98 A22p
142 ThinkPad A20m/p, A21m/p, A22m/p
For Windows 2000/Windows NT A22m
For Windows 2000 A22m
For Windows 2000 A22p
ThinkPad A20m/p, A21m/p and A22m/p
For Windows 2000/Windows NT A22p
144 ThinkPad A20m/p, A21m/p, A22m/p
continued
Miscellaneous parts
ThinkPad A20m/p, A21m/p and A22m/p
146 ThinkPad A20m/p, A21m/p, A22m/p
Optional FRUs
ThinkPad A20m/p, A21m/p and A22m/p
For 2-pin power cords
Common parts list
Power cords system
For 3-pin power cords
Power cords docking station
For 3-pin power cords
Notices
Trademarks
ThinkPad A20m/p, A21m/p and A22m/p
Notices
Part Number 23P0896
1P P/N 23P0896