Completed Installation | Ice-O-Matic GEM0956R, GEM1256R, GEM0650R

GEM0650/0956/1256 Remote

For the Installer

Completed Installation

A typical installation should generally appear as illustrated below. The best place for the remote condenser is above the ice machine, although other locations are permissible.

Roof Cut-A-Way

Page 13

Image 19

Ice-O-Matic GEM0956R, GEM1256R, GEM0650R installation manual Completed Installation

Contents

By Ice-O-Matic Pearl Ice SeriesPage Keep this manual for future reference Introduction Table Of Contents Concealed Loss or Damage Freight Claim ProcedureInspect Promptly Visible Loss or Damage Governing LAW Warranty For the Installer GEM0650/0956R GEM1256R Bin Application Ice Machine Specifications Water Limitations LocationStorage Bin Ice machine Line Sets ERC Dimensions Inches GRC1001 GRC1061 GCR2061Remote Condenser Pearl Ice Number Calculation Formula Remote Condenser LocationCalculation Example Roof Attachment Remote Condenser LocationPrecharged Line Set Routing Typical Installation Final Connections Coupling Instructions Initial Connections Water Inlet For the PlumberDrains Ice Machine For the Electrician Completed Installation Final Check List Start Up There are no adjustments to make, so replace the panelsStart Up Pre-Start Inspection Component Description Control Board GEM0650/0956/1256 Remote Electrical Sequence Water System Operation WaterWater Water Level Operation Refrigeration Refrigeration Schematic Low Condensing Temperature Pump Down Operation Performance Sanitizing and Cleaning Brush in direction of fins Condenser Maintenance Bearing Maintenance Bearing Maintenance Bin Control Sensor Sensor MaintenanceWater Sensor Auger Auger Maintenance Symptom Possible Cause Probable Correction Service Diagnosis Symptom High pressure cut out check Control System Diagnostics Water Reservoir Water Reservoir, Bin ControlBin Controls Ice Level Sensors Bearing and Breaker To Remove the Breaker Bearing Assembly To Remove the Auger Auger Replacing the Water Seal Water SealTo Remove the Water Seal Removal of the Water Seal To Replace the Water Seal To Replace the Evaporator EvaporatorTo Reassemble the Evaporator and Auger To Inspect the Gear Motor To Remove and Repair the Gear Motor AssemblyGear Motor To Check the Gear Motor Fan Blade and Motor To Remove the Condenser Fan Motor Assembly Charging Procedure Refrigeration Service Wiring Diagram GEM0650R GEM0650R Wiring Diagram Wiring Diagram GEM0956R GEM0956R Wiring Diagram Wiring Diagram GEM1256R GEM1256R Wiring Diagram What to Do Before Calling for Service Service History