Operation Performance | Ice-O-Matic GEM1256R, GEM0956R, GEM0650R

GEM0650/0956/1256 Remote	Operation: Performance
Typical Low Side Pressure:
Remote:	34-38 PSIG
Typical Discharge Pressure:
Remote:	220-275 PSIG
Typical Compressor Amp Draw:
GEM0650 115/60/1	8-9 Amps
GEM0956 208-230/60/1	4-5 Amps
GEM1256 208-230/60/1	5-6 Amps
Typical Auger Drive Motor Amp Draw:
GEM0650 115/60/1	3.1 to 3.5 Amps
GEM0956 208-230/60/1	1.6 to 1.8 Amps
GEM1256 208-230/60/1	1.6 to 1.8 Amps
Expansion Valve Superheat:	6-8 degrees
High Pressure Cut Out- Automatic Reset:	450 PSIG
Pump Down Cut Out- Automatic Reset:	15 PSIG
Refrigerant Charge: R404A
GEM0650 Remote	208 ounces
GEM0956 Remote	208 ounces
GEM1256 Remote	208 ounces

Page 24

Image 30

Ice-O-Matic GEM1256R, GEM0956R, GEM0650R installation manual Operation Performance

Contents

Pearl Ice Series By Ice-O-MaticPage Introduction Keep this manual for future reference Table Of Contents Visible Loss or Damage Freight Claim ProcedureInspect Promptly Concealed Loss or Damage Warranty Governing LAW For the Installer GEM0650/0956R GEM1256R Ice Machine Specifications Bin Application Ice machine LocationStorage Bin Water Limitations Pearl Ice Number ERC Dimensions Inches GRC1001 GRC1061 GCR2061Remote Condenser Line Sets Remote Condenser Location Calculation FormulaCalculation Example Remote Condenser Location Roof AttachmentPrecharged Line Set Routing Typical Installation Coupling Instructions Initial Connections Final Connections For the Plumber Water InletDrains Ice Machine For the Electrician Completed Installation Final Check List Pre-Start Inspection There are no adjustments to make, so replace the panelsStart Up Start Up Component Description Control Board GEM0650/0956/1256 Remote Electrical Sequence Water Level Operation WaterWater Water System Refrigeration Schematic Operation Refrigeration Low Condensing Temperature Pump Down Operation Performance Sanitizing and Cleaning Condenser Maintenance Brush in direction of fins Bearing Maintenance Bearing Maintenance Sensor Maintenance Bin Control SensorWater Sensor Auger Maintenance Auger Service Diagnosis Symptom Possible Cause Probable Correction Symptom Control System Diagnostics High pressure cut out check Water Reservoir, Bin Control Water ReservoirBin Controls Ice Level Sensors To Remove the Breaker Bearing Assembly Bearing and Breaker Auger To Remove the Auger Removal of the Water Seal To Replace the Water Seal Water SealTo Remove the Water Seal Replacing the Water Seal Evaporator To Replace the EvaporatorTo Reassemble the Evaporator and Auger To Check the Gear Motor To Remove and Repair the Gear Motor AssemblyGear Motor To Inspect the Gear Motor To Remove the Condenser Fan Motor Assembly Fan Blade and Motor Refrigeration Service Charging Procedure GEM0650R Wiring Diagram Wiring Diagram GEM0650R GEM0956R Wiring Diagram Wiring Diagram GEM0956R GEM1256R Wiring Diagram Wiring Diagram GEM1256R Service History What to Do Before Calling for Service