IMPORTANT SAFETY INSTRUCTIONS
1.Do not install portable or
2.Always maintain minimum clearances from combustible construction, see “Location Requirements” section.
3.The outdoor cooking gas appliance shall not be located under overhead unprotected combustible construction.
4.This outdoor cooking gas appliance shall be used only outdoors and shall not be used in a building, garage, or any other enclosed area.
5.Keep any electrical supply cord and fuel supply hose away from any heated surfaces.
6.Keep outdoor cooking and appliance area clear and free from combustible materials, gasoline and other flammable vapors and liquids.
7.Do not obstruct the flow of combustion and ventilation air. Keep the ventilation openings of the cylinder enclosure free and clear from debris.
8.Inspect the gas cylinder supply hose before each use of the grill. If the hose shows excessive abrasion or wear, or is cut, it MUST be replaced before using the grill. Contact your dealer and use only replacement hoses specified for use with the grill. If removal of an access plate(s) or opening of a door(s) is required for this inspection, instructions shall be provided on how to gain access for the inspection.
9.Visually check the burner flames. They should be blue. Slight yellow tipping is normal for L.P. gas.
10.Check and clean burner/venturi tube for insects and insect nest. A clogged tube can lead to fire under the grill.
11.The L.P. gas supply cylinder to be used must be:
•constructed and marked in accordance with the Specification for L.P. Gas Cylinders of the U.S. Department of Transportation (DOT) or the National Standard of Canada,
•provided with a listed overfilling prevention device.
•provided with a cylinder connection device compatible with the connection for outdoor grill appliances.
12.Always check connections for leaks each time you connect and disconnect the L.P. gas supply cylinder. See “Installation Instructions” section.
13.When the outdoor cooking gas appliance is not in use, the gas must be turned off at the supply cylinder.
14.Storage of an outdoor gas grill appliance indoors is permis- sible only if the cylinder is disconnected and removed from the outdoor gas grill.
15.Cylinders must be stored outdoors and out of the reach of children and must not be stored in a building, garage, or any other enclosed area.
16.The pressure regulator and hose assembly supplied with the outdoor gas grill must be used. A replacement pressure regulator and hose assembly specific to your model is avail- able from your outdoor grill dealer.
17.The cylinder supply system must be arranged for proper vapor withdrawal.
18.Gas cylinder must include a collar to protect the cylinder valve.
Save These Instructions
If the following information is not followed exactly, a fire causing death or serious injury may occur.
•Do not store a spare
•Never fill the cylinder beyond 80 percent full.
IMPORTANT:
This side burner is manufactured for outdoor use only.
For side burners that are to be used at elevations above 2000 feet, orifice conversion is required. See “Gas Supply Requirements” section.
It is the responsibility of the installer to comply with the minimum installation clearances specified on the model/serial rating plate. The model/serial rating plate can be found on the side panel.
Copies of the standards listed may be obtained from:
National Fire Protection Association One Batterymarch Park
Quincy, Massachusetts 02269
CSA International
8501 East Pleasant Valley Rd.
Cleveland, Ohio
The California Safe Drinking Water and Toxic Enforcement Act requires the Governor of California to publish a list of substances known to the State of California to cause cancer, birth defects, or other reproductive harm, and requires businesses to warn of potential exposure to such substances.
WARNING: This product contains a chemical known to the State of California to cause cancer, birth defects, or other reproductive harm.
This appliance can cause
In the State of Massachusetts, the following installation instructions apply:
•Installations and repairs must be performed by a qualified or licensed contractor, plumber, or gasfitter qualified or licensed by the State of Massachusetts.
•If using a ball valve, it shall be a
•A flexible gas connector, when used, must not exceed 3 feet.
3