Commercial Pool Heaters
Table of Contents |
|
General Product Information | . . . .3 |
Special Instructions | . . . .3 |
Unpacking | . . . .3 |
Codes | . . . .3 |
Warranty | . . . .3 |
Safety Information | . . . .3 |
Product Identification | . . . .5 |
Installation | . . . .6 |
Locating Pool Heater | . . . .6 |
Clearances from Combustible Construction | . . . .6 |
Base for Combustible Floors | . . . .6 |
Freeze Protection | . . . .7 |
Combustion and Ventilation Air | . . . .7 |
Combustion Air Filter | . . . .7 |
Combustion Air Options | . . . .8 |
Exhaust Fans | . . . .9 |
Venting | . . .10 |
General Information | . . .10 |
Venting Support | . . .10 |
Vertical Vent Termination Clearances and Location | . . .10 |
Sidewall Vent Termination Clearances and Location | . . .11 |
Combustion Air Inlet Piping | . . .12 |
Length of Air Inlet Piping | . . .12 |
Sidewall Air Inlet | . . .12 |
Vertical Rooftop Air Inlet | . . .13 |
Combined Air Inlet Points | . . .13 |
Vent System Options | . . .14 |
Barometric Damper Location | . . .14 |
1. Conventional Negative Draft Venting | . . .14 |
2. Vertical DirectAire™ Venting | . . .16 |
3. Sidewall Venting | . . .17 |
4. Horizontal DirectAire™ Venting | . . .20 |
5. Direct Venting | . . .21 |
6. Outdoor Installation Venting | . . .25 |
Connecting to Gas Supply | . . .26 |
Gas Pressure Test | . . .26 |
Gas Piping | . . .27 |
Connecting Gas Piping to the Pool Heater | . . .27 |
Gas Train and Controls | . . .27 |
Combination Gas Valves | . . .28 |
Venting of Combination Gas Valves | . . .28 |
Checking Gas Supply Pressure | . . .28 |
Gas Manifold Pressure Adjustment | . . .30 |
Pool Heater Piping Installation | . . .31 |
Auxiliary Mixed Water Limit Control | . . .31 |
Pumped Bypass | . . .31 |
Outdoor Operation - Outdoor | . . .31 |
Manual Operation of the | . . .32 |
Table of Contents |
|
|
Relief Valve | . . . . . . . | .34 |
Water Flow Switch | . . . . . . . | .34 |
Pump Purge Delay Option | . . . . . . . | .36 |
Service Indicator Option | . . . . . . . | .36 |
Connecting to Electrical Supply | . . . . . . . | .36 |
. . . . . . . | .36 | |
Terminal Strip Connection Options | . . . . . . . | .37 |
Operation | . . . . . . . | .38 |
Lighting Instructions | . . . . . . . | .38 |
To Turn Off Gas To Pool Heater | . . . . . . . | .39 |
. . . . . . . | .39 | |
Starting the Filter System | . . . . . . . | .39 |
Operating Temperature Control | . . . . . . . | .40 |
Programming Mode | . . . . . . . | .41 |
Error Messages | . . . . . . . | .41 |
Hot Surface Ignition System | . . . . . . . | .42 |
Operation and Diagnostic Lights | . . . . . . . | .43 |
Water Chemistry | . . . . . . . | .44 |
Pipe Size Requirements | . . . . . . . | .45 |
Circulating Pump | . . . . . . . | .46 |
Minimum Pump Performance | . . . . . . . | .46 |
Heat Exchanger | . . . . . . . | .46 |
High Water Temperature Limit Control | . . . . . . . | .46 |
Cleaning and Maintenance | . . . . . . . | .47 |
Heat Exchanger Cleaning | . . . . . . . | .48 |
Combustion and Ventilation Air | . . . . . . . | .48 |
Adjusting Differential Air Pressure | . . . . . . . | .49 |
. . . . . . . | .49 | |
Adjustment Procedure | . . . . . . . | .50 |
Servicing Hot Surface Igniter and Ignition Module | .50 | |
Ignition System Checkout | . . . . . . . | .50 |
Energy Saving Recommendations | . . . . . . . | .51 |
Sequence of Operation | . . . . . . . | .51 |
Glossary | . . . . . . . | .52 |
Wiring Box Connections | . . . . . . . | .54 |
Ladder Diagram | . . . . . . . | .56 |
Control Box Connections | . . . . . . . | .57 |
Appendix A_Unit Start Up Checklist | . . . . . . . | .58 |
Appendix B_Adjust Menu Settings for Operating Modes . | .59 | |
Revision Notes | Back Cover |
2