Manuals / Monessen Hearth / Household Appliance / Indoor Fireplace

Monessen Hearth DIS33G manual Use only TPB rock wool provided with log set, Log Placement

Models: DIS33G

1 40

Download 40 pages 27.71 Kb

Page 25

Image 25

LOG PLACEMENT

6. Place right top log (#6) on two pins to the left of right base log. See Figure 29.

Right Top Log (#6)

Pins

Figure 29 - Installing Right Top Log (#6)

Right Base

Log

PLACING ROCK WOOL

After installing logs, place TPB-RW (Rock Wool) in dime-size pieces evenly across the burner surface in between the logs. Do not add additional rock wool. See Figure 30 for the ap- proximate area to place rock wool.

Wash hands after placing rock wool. Itching may occur.

•Use only TPB rock wool provided with log set.

•Do not add additional rock wool.

Dime-Size Rock Wool

Figure 30 - Placing Rock Wool

23D8020

Page 25

Image 25

Monessen Hearth DIS33G manual Use only TPB rock wool provided with log set, Do not add additional rock wool, Log Placement

Contents

Control Type Milli-Voltand T-Stat MODEL DIS33G Natural Gas or Propane/LPGWHAT TO DO IF YOU SMELL GAS Do not try to light any applianceInstalling Canopy CONTENTSConnecting the Gas WarrantyINSTALLER IMPORTANT SAFETY INFORMATIONOWNER utility gas wells. This gas is commonly Never connect unit to private nonknown as wellhead gas IMPORTANT SAFETY INFORMATIONOPERATION PRODUCT FEATURESOptional T-stat Sensor On/Off Switch Optional Face Plate Fireplace ScreenNATURAL GAS PRODUCT FEATURES AND SPECIFICATIONSMilli-Voltand T-StatPressure PROPANE/LPGGETTING STARTED WHAT YOU WILL NEED FOR INSTALLATIONMAKE SURE YOU HAVE RECEIVED ALL PARTS INSTALLING CANOPY GENERAL INSTALLATION INFORMATIONREMOVING SCREEN Figure 3 - Installing CanopyCODES Do not install the heater …American National Standards Institute, Inc National Fire Protection Association, IncBTU/Hr = WARNING WARNING2 Ft x W Ft x H Ft 151/2CLEARANCES AND HEIGHT REQUIREMENTS Accessory Face PlatesSmall Large21/2 CLEARANCES and HEIGHT REQUIREMENTSFigure 7 - Measuring Heat Resistant Material for MantelCombustible Material 5 Non-combustible Material CLEARANCES and HEIGHT REQUIREMENTS23D8020 225/8 16 331/2 FIREPLACE FRAMING16 331/2 271/2 331/2Figure 15 - Removing Grate and Base Assembly SECURING HEATER TO FLOORFigure 16 - Securing Firebox to Floor or Hearth Figure 17 - Gas Connection CONNECTING THE GASAccess Door for Gas Line Cord Protector CONNECTING THE GASFigure 18 - Access Holes Manual Gas Shutoff Recommended OutletMILLIVOLT CONTROL Figure CHECKING GAS PRESSURETest Port “OUT” Figure 19 - Pressure Test Point LocationWall Switch On/Off Switch TH = TP = TP/TH = ELECTRICAL WIRING MILLI-VOLTSwitch ODS Pilot Millivolt Valve Spade Terminal SwitchELECTRICAL WIRING MILLI-VOLT CONNECTING REMOTE RECEIVER FigureFigure 21 - Installing Remote Receiver THESE INSTRUCTIONS SUPERCEDE THE SECTIONNever attempt to service heater while ELECTRICAL WIRING FANit is plugged in, operating, or hot Burns and/or electrical shock couldINSTALLING CHARRED TIMBER LOGS ON BURNER LOG PLACEMENTPins Figure 23 - Installing Rear Log #1Left Base Log #3 Pins LOG PLACEMENTFigure 25 - Installing Left Base Log #3 Figure 26 - Installing Right Front Log #4Figure 27 - Installing Left Top Log #5 LOG PLACEMENTLeft Top Log #5 Pin Bottom Center Pin 23D8020Do not add additional rock wool Use only TPB rock wool provided with log setLOG PLACEMENT Right Top Log #6 PinsCHECKING THE PILOT FLAME FLAME APPEARANCETHERMOSTAT AND MILLI-VOLTCONTROL ThermocoupleOPERATING INSTRUCTIONS CHECKING THE BURNER FLAMEGlowing Embers Figure 33 - Correct Appearance of Rear FlamesOPERATING INSTRUCTIONS FOR YOUR SAFETY READ BEFORE LIGHTINGWHAT TO DO IF YOU SMELL GAS WARNING WARNINGLIGHTING INSTRUCTIONS MILLI-VOLT/THERMOSTATCONTROLTO TURN OFF GAS TO HEATER OPERATING INSTRUCTIONSBLOWER OPERATION MATCH LIGHTING INSTRUCTIONSOPERATING INSTRUCTIONS AND BLOWER OPERATION CLEANING AND SERVICING OBSERVED PROBLEM TROUBLESHOOTINGPOSSIBLE CAUSE REMEDYOBSERVED PROBLEM TROUBLESHOOTINGPOSSIBLE CAUSE REMEDY8 8 28 8 3 ILLUSTRATED PARTS BREAKDOWN23D8020 Description REPLACEMENT PARTS LISTDIS33N/P OPTIONAL FACE PLATE6 5 3 8A 4 7 2 8B ILLUSTRATED PARTS BREAKDOWN23D8020 Accessories REPLACEMENT PARTS LISTDescription DIS33NILLUSTRATED PARTS BREAKDOWN CHARRED TIMBER LOGS#4 #5 #6 23D8020 FIVE YEAR WARRANTY LIMITED LIFETIME WARRANTY POLICYBASIC WARRANTY Technical Services Monessen Hearth Systems