Manuals / Monessen Hearth / Household Appliance / Indoor Fireplace

Monessen Hearth DIS33G manual Replacement Parts List, Description, DIS33N, DIS33P, Common Parts

Models: DIS33G

1 40

Download 40 pages 27.71 Kb

Page 37

Image 37

REPLACEMENT PARTS LIST

REPLACEMENT PARTS ARE AVAILABLE THROUGH YOUR RETAILER.

Item	Description	Qty	DIS33N	DIS33P
Common Parts
1	Piezo Ignitor	1	14D0503	14D0503
2	Piezo Wire	1	00K0632	00K0632
3	Burner	1	70D0104	70D0104

Milli-Volt Control

4	Control Valve	1	14D0467	14D0468
5	Burner Injector	1	58D0051	58D0052
6	ODS Pilot Assembly	1	14D0473	14D0477
8A	Pilot/On/Off
	Knob Extension	1	37D0010	37D0010
8B	Hi/Lo Knob	1	37D0011	37D0011
7	On/Off Switch	1	32D0232	32D0232

Accessories

	Flex Connector		Flexcon18	All Models
	Wall Switch Kit		MVWS	All Models
	Wall Thermostat Kit		WT	All Models
	Hand Held Remote		RCB/RCM	All Models
			WMTD
	Hand Held Thermostat		RCST, RCT	All Models
	Remote		WWTD
	Thermostat Sensor Kit		TS	All Models
	Rock Wool Bag		TPB18-RW	All Models

23D8020

Page 37

Image 37

Monessen Hearth DIS33G Replacement Parts List, Description, DIS33N, DIS33P, Common Parts, Milli-VoltControl, Accessories

Contents

Control Type Milli-Voltand T-Stat MODEL DIS33G Natural Gas or Propane/LPGWHAT TO DO IF YOU SMELL GAS Do not try to light any applianceInstalling Canopy CONTENTSConnecting the Gas WarrantyINSTALLER IMPORTANT SAFETY INFORMATIONOWNER utility gas wells. This gas is commonly Never connect unit to private nonknown as wellhead gas IMPORTANT SAFETY INFORMATIONOPERATION PRODUCT FEATURESOptional T-stat Sensor On/Off Switch Optional Face Plate Fireplace ScreenNATURAL GAS PRODUCT FEATURES AND SPECIFICATIONSMilli-Voltand T-StatPressure PROPANE/LPGGETTING STARTED WHAT YOU WILL NEED FOR INSTALLATIONMAKE SURE YOU HAVE RECEIVED ALL PARTS INSTALLING CANOPY GENERAL INSTALLATION INFORMATIONREMOVING SCREEN Figure 3 - Installing CanopyCODES Do not install the heater …American National Standards Institute, Inc National Fire Protection Association, IncBTU/Hr = WARNING WARNING2 Ft x W Ft x H Ft 151/2CLEARANCES AND HEIGHT REQUIREMENTS Accessory Face PlatesSmall Large21/2 CLEARANCES and HEIGHT REQUIREMENTSFigure 7 - Measuring Heat Resistant Material for MantelCombustible Material 5 Non-combustible Material CLEARANCES and HEIGHT REQUIREMENTS23D8020 225/8 16 331/2 FIREPLACE FRAMING16 331/2 271/2 331/2Figure 15 - Removing Grate and Base Assembly SECURING HEATER TO FLOORFigure 16 - Securing Firebox to Floor or Hearth Figure 17 - Gas Connection CONNECTING THE GASAccess Door for Gas Line Cord Protector CONNECTING THE GASFigure 18 - Access Holes Manual Gas Shutoff Recommended OutletMILLIVOLT CONTROL Figure CHECKING GAS PRESSURETest Port “OUT” Figure 19 - Pressure Test Point LocationWall Switch On/Off Switch TH = TP = TP/TH = ELECTRICAL WIRING MILLI-VOLTSwitch ODS Pilot Millivolt Valve Spade Terminal SwitchELECTRICAL WIRING MILLI-VOLT CONNECTING REMOTE RECEIVER FigureFigure 21 - Installing Remote Receiver THESE INSTRUCTIONS SUPERCEDE THE SECTIONNever attempt to service heater while ELECTRICAL WIRING FANit is plugged in, operating, or hot Burns and/or electrical shock couldINSTALLING CHARRED TIMBER LOGS ON BURNER LOG PLACEMENTPins Figure 23 - Installing Rear Log #1Left Base Log #3 Pins LOG PLACEMENTFigure 25 - Installing Left Base Log #3 Figure 26 - Installing Right Front Log #4Figure 27 - Installing Left Top Log #5 LOG PLACEMENTLeft Top Log #5 Pin Bottom Center Pin 23D8020Do not add additional rock wool Use only TPB rock wool provided with log setLOG PLACEMENT Right Top Log #6 PinsCHECKING THE PILOT FLAME FLAME APPEARANCETHERMOSTAT AND MILLI-VOLTCONTROL ThermocoupleOPERATING INSTRUCTIONS CHECKING THE BURNER FLAMEGlowing Embers Figure 33 - Correct Appearance of Rear FlamesOPERATING INSTRUCTIONS FOR YOUR SAFETY READ BEFORE LIGHTINGWHAT TO DO IF YOU SMELL GAS WARNING WARNINGLIGHTING INSTRUCTIONS MILLI-VOLT/THERMOSTATCONTROLTO TURN OFF GAS TO HEATER OPERATING INSTRUCTIONSBLOWER OPERATION MATCH LIGHTING INSTRUCTIONSOPERATING INSTRUCTIONS AND BLOWER OPERATION CLEANING AND SERVICING OBSERVED PROBLEM TROUBLESHOOTINGPOSSIBLE CAUSE REMEDYOBSERVED PROBLEM TROUBLESHOOTINGPOSSIBLE CAUSE REMEDY8 8 28 8 3 ILLUSTRATED PARTS BREAKDOWN23D8020 Description REPLACEMENT PARTS LISTDIS33N/P OPTIONAL FACE PLATE6 5 3 8A 4 7 2 8B ILLUSTRATED PARTS BREAKDOWN23D8020 Accessories REPLACEMENT PARTS LISTDescription DIS33NILLUSTRATED PARTS BREAKDOWN CHARRED TIMBER LOGS#4 #5 #6 23D8020 FIVE YEAR WARRANTY LIMITED LIFETIME WARRANTY POLICYBASIC WARRANTY Technical Services Monessen Hearth Systems

DIS33N

DIS33P

Common Parts

Milli-Volt Control

Accessories