Manuals / New Buck Corporation / Household Appliance / Stove

New Buck Corporation 94NC installation instructions Table Of Contents

Models: 94NC

1 29

Download 29 pages 51.28 Kb

Page 3

TABLE OF CONTENTS
Important Instructions	2
SECTION I: Introduction	3
Type of wood and loading procedures	3
Parts List	4
SECTION II: Masonry Insert Installation	5
Installation Preparation-Fireplace	6
Mounting Trim Panels	7
SECTION III: Residential Freestanding Installation	11
Floor Protection	12
Installing thimble through combustible wall	14
Final Check	18
Clearances: Residential / Single Wall pipe	19
SECTION IV: Wood Heater Safety	20
SECTION VI: Operation	21
Room Air Blower Operation	22
SECTION VII: Troubleshooting	23
Warranty	26

Image 3

New Buck Corporation 94NC installation instructions Table Of Contents

Contents

SAFETY NOTICE FIREPLACE INSERT & FREESTANDINGMODEL 94NC NON-CATALYTICUNIT Page TABLE OF CONTENTS IMPORTANT INSTRUCTIONS INSTALLATION, OPERATION, ANDMAINTENANCE INSTRUCTIONS MODEL 94NC BEFORE INSTALLING YOUR NEW BUCK STOVEINTRODUCTION SECTIONMODEL 94NC WOOD STOVE EPA COMPLIANCE STATUSMINIMUM CLEARANCE MASONRY INSERT MASONRY INSERT INSTALLATIONSECTION INSTALLATION OPTIONS POSSIBLE TOOLS NEEDED FOR INSTALLATIONINSTALLATION PREPARATION MASONRY INSERT INSTALLATIONSTARTER PIPE SEAL TRIM PANELS AND UNDER TEMPERATURE CAULKAIRTIGHT INSU LATED CLEAN OUT REMOVE DAMPER OR WIRE IT OPENPOSITIONING INSTALLATION PROCEDUREPOSITIONING HEATER BEHINDFINAL CHECK THE UNIT IS PAINTED WITH A SPECIALLY FORMULATED HIGH TEMPERATURE PAINT THAT CURES DURING THE FIRST TWO OR THREE FIRINGS. YOU MAY NOTICE A SLIGHT SMOKING EFFECT AND AN ODOR OF BURNING PAINT WHEN YOU BUILD THE FIRST FIRES. THIS IS NORMAL AND IS NOT A CAUSE FOR ALARM. IN SOME CASES, THESE FUMES WILL ACTIVATE A SMOKE ALARM. OPENING A WINDOW NEAR THE UNIT WILL ALLOW THESE FUMES TO ESCAPE. DO NOT BUILD A LARGE, ROARING FIRE UNTIL THIS CURING IS COMPLETE OR THE HEATER FINISH MAY BE DAMAGED PREPARING STOVE FOR INSTALLATION SECTION RESIDENTIAL FREESTANDING INSTALLATIONFloor Protection ChimneyDETERMINING CHIMNEY LOCATION Installing a thimble through combustible wall B. Wall Exit Into Metal Tee-Box Page Connectors may pass through walls or partitions constructed of combustible material if connector is FINAL CHECK CLEARANCES FOR MODEL 94NC SECTION WOOD HEATER SAFETY BUILDING A FIRE SECTION VII OPERATIONPage ROOM AIR BLOWER OPERATIONPOSSIBLE CAUSE SECTION TROUBLESHOOTINGPROBLEM SOLUTIONContinued TROUBLESHOOTINGPROBLEM SOLUTIONREPLACEMENT PARTS FOR MODEL 94NC DescriptionPart Number PRODUCTS COVERED NEW BUCK CORPORATION NBCWARRANTY TIME PERIODS PROCEDURECONDITIONS AND EXCLUSIONS OTHER RIGHTSOWNER REGISTRATION CARD