Manuals / Polaris / Lawn and Garden / Portable Generator

Polaris P3000iE manual First Use Instructions, Wheel Kit Installation, Wheel assembly

Models: P3000iE

1 81

Download 81 pages 53.64 Kb

Page 26

Image 26

FIRST USE INSTRUCTIONS

Wheel Kit Installation

The unit comes with the rubber mounting feet installed. If you wish to install the wheel kit, please perform the following procedure.

1.Axle assembly (1)

2.Locking swivel wheel (2)

3.Bolt M8X16 (4)

4.Wheel (2)

5.Bolt M6X16 (8)

Wheel assembly

First remove all four rubber mounting feet.

Put a washer on each side of the wheel then slide them on the axle securing with a lock pin.

1.Wheel (2)

2.Axle (1)

3.Lock pin (2)

4.Washer (4)

Locking swivel wheel

Secure each locking swivel wheel with 4 M6X16 bolts.

1.Locking swivel wheel

2.Bolt M6X16

Note: Make sure to push two universal wheels to "lock" position when the generator is running, in transportation and storage.

Page 26

Image 26

Polaris P3000iE manual First Use Instructions, Wheel Kit Installation, Wheel assembly, Locking swivel wheel

Contents

DEATH POLARIS POWER P3000iEOperator’s Manual Australian model TABLE OF CONTENTS INTRODUCTION WelcomeIntended Use Safety PrecautionsINTRODUCTION Warnings, Cautions and Notices Signal Words and Safety TermsINTRODUCTION ALCOHOL OR DRUG USESerial Number INTRODUCTIONIdentification Numbers and Locations General SAFETYSafety Warnings and Precautions SAFETY Before and During OperationDo not refuel while engine is running SAFETYBefore and During Operation SAFETY Operator SafetySAFETY Fuel SafetySAFETY Carbon Monoxide SafetyFire Safety SAFETYElectrical Safety Extension Cord Information SAFETYFire Safety Equipment ModificationsOutdoor Use ONLY Danger Label SAFETYCarbon Monoxide Warning DANGERSAFETY NOMENCLATURE CONTROLS AND FEATURESGenerator Components DESCRIPTIONDESCRIPTION CONTROLS AND FEATURESNOMENCLATURE Ground TerminalLow Oil Indicator CONTROLS AND FEATURESIndicator Panel Overload IndicatorIgnition Switch CONTROLS AND FEATURESSMART Throttle Switch Fuel Valve LeverAC Receptacles CONTROLS AND FEATURESDC Receptacle and Fuse Ground Terminal CONTROLS AND FEATURESFuel Volume Indicator Starter Recoil GripFIRST USE INSTRUCTIONS Adding Engine OilFIRST USE INSTRUCTIONS Fuel RecommendationFIRST USE INSTRUCTIONS Adding FuelFIRST USE INSTRUCTIONS Wheel Kit InstallationWheel assembly Locking swivel wheelFuel Line PRE-OPERATIONINSPECTIONEngine Oil Fuel LevelFuel Recommendations OPERATIONSafe Operating Precautions Refueling1.Remove the fuel tank cap A OPERATIONRefueling DANGER OPERATIONBefore Starting the Engine Starting the EngineStarting the Engine 6. To start the generator using the ignitionOPERATION Stopping the Engine OPERATIONStarting the Engine OPERATION AC OperationAC Capacity OPERATIONAC Operation Wattage Reference Table OPERATIONAC Capacity RUNNINGOPERATION Power ManagementConnecting the Battery Charging Cable included DC OperationDC Operation Connecting the Battery Charging CableOPERATION OPERATION Connecting the Battery Charging CableDisconnecting the Battery Charging Cable DC OperationSMART Throttle System OPERATIONAir Conditioning Operation Connections to a Building Electrical System Standby PowerOPERATION System GroundCarburetor Modification OPERATIONHigh Altitude Use Source of Emissions OPERATIONEmission Control System Information AlterationsOPERATION Problems Affecting EmissionsReplacement Parts MAINTENANCE Importance of MaintenanceSafety Precautions MAINTENANCEMaintenance Safety Periodic Maintenance Chart MAINTENANCEPeriodic Maintenance MAINTENANCE Opening the Service DoorFuel System MAINTENANCEOpening the Service Door Fuel Line InspectionMAINTENANCE Fuel Tank StrainerOil Recommendation MAINTENANCEEngine Oil Oil Level InspectionMAINTENANCE Oil ChangeOil Change MAINTENANCE7.Re-installthe oil drain bolt B Air Filter Inspection MAINTENANCEAir Filters Spark Plug MAINTENANCESpark Plug Inspection and Replacement 8.Using a wire-typefeeler gauge MAINTENANCESpark Plug Inspection and Replacement Battery Safety MAINTENANCEBattery Accessing the BatteryCHARGE TIME MAINTENANCEBattery Charging Sealed Only STATE OFSpark Arrestor MAINTENANCESpark Arrestor Maintenance Transporting the Generator TRANSPORTATION AND STORAGETransportation Storage Preparation TRANSPORTATION AND STORAGEStorage Accessing the Fuel Tank TRANSPORTATION AND STORAGETRANSPORTATION AND STORAGE Draining Fuel from the Fuel Tank and CarburetorTRANSPORTATION AND STORAGE Fogging the EngineTRANSPORTATION AND STORAGE Battery StorageStorage Precautions Generator ExerciseP3000iE SPECIFICATIONSPOLARIS Power Generator ALTERNATORGENERATOR SPECIFICATIONSP3000iE POLARIS Power Generator ENGINE OILDIAGRAMWIRING Inverter ModuleSOLUTION TROUBLESHOOTINGSOLUTION Engine Will Not Turn OverSOLUTION TROUBLESHOOTINGEngine Lacks Power SOLUTIONSOLUTION TROUBLESHOOTINGSOLUTION Engine Pings or KnocksSOLUTION TROUBLESHOOTINGNo Power at DC Receptacle SOLUTIONEngine Stops or Loses Power TROUBLESHOOTINGNo Power at AC Receptacles SOLUTIONWARRANTY REGISTRATION FORM WARRANTYABOUT THIS WARRANTY DOCUMENT POLARIS POWER GENERATOR WARRANTYWARRANTY POLICY WARRANTYPOLARIS POWER GENERATOR WARRANTY WARRANTY PERIODWARRANTY EXCLUSIONS WARRANTYPOLARIS POWER GENERATOR WARRANTY POLARIS POWER GENERATOR OWNER RESPONSIBILITY WARRANTYPOLARIS POWER GENERATOR WARRANTY WARRANTY EXCLUSIONSWARRANTY IMPORTANT NOTICEDATE/HOURS MAINTENANCE LOGSERVICE COMMENTSINDEX INDEX