QUICK FACTS
CALL 1-888-559-8550
TO FIND A LOCAL AUTHORIZED SERVICE CENTER NEAR YOU
FOR REPAIRS AND SERVICE PART PURCHASES.
| GAS | Use fresh high quality gas. |
| Add stabilizer to fuel tank and run engine for 5 minutes before storage. | |
|
| |
|
|
|
|
| Pump oil: Refer to owners manual supplied with this unit. |
|
| Some units (PCV2021) do not require pump oil. |
| OIL | Engine oil: Refer to engine manual supplied with this unit. |
|
| Some units are equipped with a low oil sensor and adequate oil must be added or the unit |
|
| will not start. |
|
|
|
|
| Use only cold water. |
| WATER | Don't operate unit with clogged or missing water filter/screen. |
|
| Don't operate unit without adequate water supply to pump. Adequate water supply is a |
|
| minimum of 20 psi and 5 gpm. |
|
|
|
| PRESSURE | The pressure setting is preset at the factory to achieve optimum cleaning. If you need to |
| ADJUSTMENT | lower the pressure setting, refer to the owners manual for proper procedure. |
|
|
|
| PUMP | Pull gun trigger every 2 minutes while engine is running. |
| Don't allow water to freeze in pump. | |
|
| |
|
| Siphon RV antifreeze into pump for cold weather storage or long term storage. |
|
|
|
| Never leave unit running for more than 2 minutes without pulling gun trigger; doing so will | |
|
| destroy pump and void warranty. |
|
|
|
| THERMAL | Pump is equipped with a thermal relief valve. If the water overheats, this valve will open |
| and allow a gush of water to escape. Once the water is released, the valve closes allow- | |
| RELIEF VALVE | |
| ing the pump to operate normally. | |
|
| |
|
|
|
| HOSE | Don't allow hoses to contact the HOT engine muffler during or after use. |
| Never pull the hose to move the unit. | |
|
| |
|
|
|
|
| Do not adjust or attempt maintenance without consulting engine manual or an authorized |
| ENGINE | engine service center. |
| Add stabilizer to fuel tank and run engine for 5 minutes before storage. | |
|
| |
|
| Always turn on the water before starting the engine. |
|
|
|
| SOAP CHEMICALS | Use only soaps and chemicals designed for pressure washer use. |
|
|
|
| NOZZLE | Keep nozzle unclogged. Refer to manual for cleaning procedures. |
| Chemical/soap cannot be siphoned in high pressure setting. Only in low setting. | |
|
| |
|
|
|
| MAINTENANCE | Follow recommended maintenance schedule for engine & pump. Refer to manuals. |
| SCHEDULE | |
|
| |
|
|
|
|
| Draw clean water through chemical inlet. |
| STORAGE OR WIN- | Add stabilizer to fuel tank and run engine for 5 minutes before storage. |
| TER STORAGE | Don't allow water to freeze in pump, gun, wand or hoses. |
|
| Siphon RV antifreeze into pump for cold weather storage or long term storage. |
|
|
|
ALWAYS REFER TO THE MANUALS SUPPLIED WITH THIS UNIT
D22885