R
Cape Cod Wood Stove
DOOR & GASKET
MAINTENANCE
Periodically check the door gasket for proper seal. As the gasket compresses or “seats” during use, it may become necessary to adjust or tighten the door latch either by removing spacer washers, shown below (at least one washer must be left in place) or, by replacing the gasket material as wear or damage to the gasket material can cause air leakage into the firebox resulting in overfiring and loss of efficiency. A replacement gasket, part #23434A, is available from your Dealer.
Latch Cam
Door Cross Section (example)
Locknut
Handle
Teflon Washer
Spacing Washers DO NOT REMOVE
Square Key
KAOWOOL INSULATING BAFFLE BLANKET
832-3390
Kit Includes: One 1/2” thick blanket 24" x 25"
cut to fit.
Tools Required: Straight edge, measuring tape,
razor knife, gloves, safety glasses and dust mask.
1.Lay Kaowool Blanket on a flat, protected sur- face, to prevent scratching the surface when you cut the blanket.
2.Measure and mark the dimensions on the Kaowool Blanket. (see Figure A).
3.Place straight edge on the blanket, and using your razor knife, cut through the blanket.
Figure A
104.0°
9.0"
25.00
32198A February 15, 2002 | Page 35 |
