Manuals / Quadra-Fire / Household Appliance / Stove

Quadra-Fire CASTILE-CLG, CASTILE-MBK Straight Out, Degree, Castile Pellet Stove Through The Wall

Models: CASTILE-CCR CASTILE-PMH CASTILE-CLG CASTILE-MBK

1 44

Download 44 pages 30.22 Kb

Page 13

Castile Pellet Stove

R

B. Through The Wall

Horizontal termination cap must be a minimum of 12 inches. (305mm) from the wall. Approved for mobile home instal- lations. Must use 3 or 4 inch (76-102mm) “L” or “PL” listed pellet venting or listed double wall pipe and a Quadra-Fire Outside Air Kit in mobile homes.

NOTE:

In Canada, where passage through a wall or partition of combustible construction is desired, the installation shall conform to CAN/CSA-B365

	Straight Out	2 in.
	Straight Out	(51mm)
		Minimum
	6 in.		Horizontal
	6 in.	Wall	Termination
	(152mm)	Wall	Termination
	(152mm)	Thimble	Cap
	Minimum	Thimble	Cap
	Minimum
	From Glass
		12 in.
		(305mm)
		Minimum
		Noncombustible Hearth Pad
	Figure 13.1

45 Degree

Illustration shows venting going in both directions.

Choose which one is best for your installation.

Wall

Thimble

2 in. (51mm) Minimum

2 in. (51mm) Minimum

Figure 13.2

October 11,, 2005

250-6422D

Page 13

Image 13

Quadra-Fire CASTILE-CLG, CASTILE-MBK, CASTILE-CCR, CASTILE-PMH Straight Out, Degree, Castile Pellet Stove Through The Wall

Contents

Castile Pellet Stove Location Back side of left side panel Castile Pellet Stove Table of Contents Listing and Code Approvals Getting Started Design, Installation & Location Fire Safety ConsiderationsAppliance Location Thermostat Location Measuring Standards Castile Pellet Stove Tools And Supplies NeededInspect Appliance & Components and Pre-Use Check List Fire Risk Appliance Dimensions 3Dimensions and Clearances Castile Pellet Stove Clearances to Combustibles UL and ULC Castile Pellet Stove Hearth Pad Requirements UL and ULC Exception for Horizontal InstallationsHearth Pad Requirements Chimney and Exhaust Connection Vent InformationVenting Termination Requirements Castile Pellet Stove Equivalent Feet of Pipe Pipe Selection ChartExample of 3 Elbow-Rear Vent Termination Calculaton See Figure Alcove Venting Systems Degree Straight OutCastile Pellet Stove Through The Wall Through The Wall & Vertical Castile Pellet Stove Vertical Alternate Masonry Castile Pellet Stove Masonry Mobile Home Outside Air Kit Instructions 7Appliance Set-Up Rear Vent and Rear Vent to Top Vent Adapter Installation Top Vent Adapter InstallationInstalling the Top Vent Adapter Castile Pellet Stove Leg Leveling System Optional TOP LOG Castile Pellet Stove Thermostat Installation Fuel Size And Material General Operating Information Operating Instructions Feed Rate Adjustment Instructions Fire CharacteristicsCastile Pellet Stove Before Your First Fire Starting Your First Fire Castile Pellet Stove Iginition Cycles Frequently Asked Questions Symption TroubleshootingPossible Cause Corrective Action Page Page 10Maintaining & Servicing Your Appliance Cleaning Ash Pan Frequency As neededTypes of Fuel Task Heat Exchanger Tubes Cleaning Rods Cleaning the Hopper Cleaning the Exhaust Path Frequency As neededCleaning Convection Blower Requires No Lubrication Cleaning Exhaust Blower Requires No Lubrication Section Castile Pellet Stove High Ash Fuel Content Maintenance Exhaust Blower Replacement Convection Blower Replacement Thumb Screw Igniter Replacement Glass Replacement Component Function Reference Materials Wiring Harness See .1 below Vacuum SwitchSnap Disc #1 Convection Blower 125F Snap Disc #2 Thermostat Override 175tF Castile Pellet Stove Component Locations Description Part Number Castile Pellet Stove Exploded Views Part Description Beg. Manufacture Date September Service Parts Castile Pellet Stove Service Parts and Accessories Appliances Accessories Date of Service Performed By Description of Service Service and Maintenance LOG Castile Pellet Stove Service and Maintenance LOG Cont’d Castile Pellet Stove Warranty Policy Lifetime Warranty Telephone Contact Information