R
Isle Royale Wood Stove
|
|
|
|
|
|
1. |
| Place the unit in a location near the final instal- |
|
| lation area and follow the procedures below. |
2. |
| Open the stove and remove all the parts and |
|
| articles packed inside. Inspect all the parts and |
|
| cast iron body for shipping damage. Contact |
|
| your dealer if any irregularities are noticed. |
3. |
| All safety warning have been read and fol- |
|
| lowed. |
4. |
| This Owner's Manual has been read. |
5. |
| Floor protection requirements have been met. |
6. |
| Chimney connector is properly installed. |
7. |
| The proper clearances from the stove and chim- |
|
| ney to combustibles materials have been met. |
8. |
| The masonry chimney is inspected by a pro- |
|
| fessional and is clean, or the |
|
| metal chimney is installed according to the |
|
| manufactuer'rs instrucitons and clearances. |
9. |
| The chimney meets the required minimum |
|
| height. |
10. |
| All labels have been removed from the glass |
|
| doors. |
11. |
| Plated surfaces have been wiped clean. |
CAUTION!
DO NOT TILT THE UNIT ON THE CAST IRON LEGS. Lift the unit upright and place it into position on the floor protector.
TABLE OF CONTENTS |
|
Listings & Safety Notices | 3 |
Serial Number Label Location | 2 |
3 | |
Dimensions | 5 |
Vent Specifications | 5 |
Clearances |
|
Top & rear vent installations | 6 |
Floor protection | 7 |
Locations your stove | 7 |
Alternate floor protection calculation | 8 |
Installation |
|
Reversible flue collar | 8 |
Rear flue deflector cover plate | 8 |
Chimney height requirements & draft | 9 |
9 | |
Flue & venting systems | 10 |
Chimney connector | 10 |
Masonry chimney | 10 |
Solid pack chimney with |
|
Metal supports as a thimble | |
Masonry fireplace | 13 |
Metal prefabricated chimney | 14 |
Mobile home installation | 15 |
Outside air kit installation | 16 |
Blower | 16 |
Operation |
|
Burning process | 17 |
Air controls | 17 |
Heat output setting | 18 |
Operation of | 18 |
Building a fire | 19 |
Opacity | 19 |
Burn rates | 20 |
Wood selection and storage | 20 |
Blower operating instructions | 20 |
Maintenance |
|
Creosote formation & removal | 21 |
Chimney cleaning | 21 |
Ash removal | 21 |
Overfring | 21 |
Firebrick | 21 |
Glass care & replacement | 21 |
Plated Surfaces | 22 |
Brick replacement | 23 |
Door & gasket | 23 |
Exploded view | 24 |
Accessories & Service Part | 25 |
Service & Maintenance Log | 26 |
Warranty | 27 |
Contact Information | 28 |
February 4, 2005 | Page 3 |