Manuals / Sterling / Household Appliance / Heat Pump

Sterling GG-90, GG-75, GG-60, GG-45, GG-120, GG-30, GG-105 ELECTRICAL CONNECTIONS continued

Models: GG-105 GG-30 GG-120 GG-45 GG-60 GG-75 GG-90

1 44

Download 44 pages 56.75 Kb

Page 14

Image 14

ELECTRICAL CONNECTIONS (continued)

Figure 11B -Tubular Propeller Units 30-120 with Natural and Propane (LP) Gas with Single Stage Gas Control and Honeywell Control Board

NOTICE: See Figures 7, 8, 9, 10B, 10C, 11B and 11C for connecting the thermostat to the unit heater. If using a standard low voltage thermostat with a sub-base switch for fan control,connect the G terminal of the thermostat to the G terminal of the unit heater.

Page 14

Image 14

Sterling GG-90, GG-75, GG-60, GG-45, GG-120, GG-30, GG-105 specifications ELECTRICAL CONNECTIONS continued

Contents

FOR RESIDENTIAL INSTALLATIONS TABLE OF CONTENTS DESCRIPTIONGENERAL SAFETY INFORMATION PERFORMANCE DATA† DIMENSIONAL DATA - inches mmUnit Size MOTOR DATA Motor HPDIMENSIONS .XXX STANDARD UNITS DIMENSIONS IN PARENTHESIS XXX MILLIMETERSINSTALLATION INSTALLATION continued GAS PIPING PIPE INSTALLATION ELECTRICAL CONNECTIONS Figure 11A - Honeywell Control Board ELECTRICAL CONNECTIONS continuedFigure 10A - UT Control Board ELECTRICAL CONNECTIONS continued ELECTRICAL CONNECTIONS continued ELECTRICAL CONNECTIONS continued Figure 11B -TubularPropeller Units 30-120with Natural and Propane LP Gas with Single Stage Gas Control and Honeywell Control BoardELECTRICAL CONNECTIONS continued Figure 11C -TubularPropeller Units 30-120with Natural and Propane LP Gas with OptionalTwo Stage Gas Control and Honeywell Control BoardVENTING Venting Categories ADDITIONAL REQUIREMENT FOR CANADIAN INSTALLATIONSVENTING - GENERAL GUIDELINES CategoryHORIZONTALLY VENTED, CATEGORY I - Figure STANDARD COMBUSTIONVERTICALLY VENTED, CATEGORY I - Figure Maximum Number D6838CVent Maximum HorizontalFigure 14 - Vent Support D- 06839AHORIZONTALLY VENTED, CATEGORY III - Figure STANDARD COMBUSTIONVERTICALLY VENTED, CATEGORY III - Figure STANDARD COMBUSTIONFigure 15C - Type B Draft Hood Connector VENTING continued Figure FigureVENTING continued Figure FigureINSTALLATION - VENTING - CATEGORY SEPARARTED COMBUSTIONFigure 20 - Concentric Vent Box SEPARATED COMBUSTION VENTING continuedTable 6 - Concentric Vent Box Dimensions Figure 21 - Concentric Vent Installation Figure 22 - Vertical Intake/Vent InstallationVENTING continued Figure 23 - Horizontal Intake/Vent InstallationFigure 24 - Horizontal Intake/Vent Installation Building Overhang 3-0Min 0.9M MinEXHAUST AIR COLLAR SEPARATED COMBUSTION VENTING continuedAIR INLET COLLAR VERTICAL TERMINATIONDIRECT SPARK IGNITION OPERATIONPOWER VENTED PROPELLER UNITS Table 7 - Main Burner Oriﬁce Schedule PRIMARY AIR SHUTTER ADJUSTMENTGAS INPUT RATE TUBULAR UNIT HEATER HIGH ALTITUDE DERATIONMAINTENANCE POSSIBLE CAUSES Table 9 - Tubular Propeller Troubleshooting GuideSYMPTOMS CORRECTIVE ACTIONCORRECTIVE ACTION SYMPTOMSPOSSIBLE CAUSES R. Cold air is delivered during CHECK/REPAIR LED STATUSINDICATES CHECK/REPAIR PATTERNSTATUS ItemDescription IDENTIFICATION OF PARTSRESIDENTIAL TUBULAR 30-120MBH UNIT SIZES IDENTIFICATION OF PARTS Figure 29 - Power Ventor AssemblyPressure Switch RESIDENTIAL TUBULAR 30-120MBH UNIT SIZESHOW TO ORDER REPLACEMENT PARTS LIMITED WARRANTY1, 2 - Unit Type UT GAS HEATING With power and gas on PRE-INSPECTIONINFORMATION With power and gas offWith power and gas off GAS EQUIPMENT START-UPHVAC PRODUCTS