TROUBLESHOOTING CHART
| Problem | Possible Cause | Solution | ||
| Odor in cabinet | Interior needs cleaning. | Clean the interior using a solution of baking |
| |
|
|
|
| soda and war water or water and mild soap | |
| Unit operates but does not | The unit has just been started and it | Typical ice production is 2 lbs per day. Allow |
| |
| produce any ice | has been less than 24 hours. | for the freezer section to reach temperature | ||
|
|
|
| and the ice maker to cycle and accumulate | |
|
|
|
| ice. | |
|
|
| Water supply is not turned on. | Turn on water supply to the unit. | |
|
|
| Inadequate water pressure to unit. | Water pressure must be at a minimum 20 psi. | |
|
|
| The ice maker bale arm is in the | When the ice maker arm is in the uppermost | |
|
|
| uppermost position | position, the ice maker is off. Flip the bale | |
|
|
|
| arm down to turn on the ice maker. | |
|
|
| Freezer section has not reached | Allow the freezer section to reach | |
|
|
| temperature. | temperature. | |
|
|
| Thermostat control knob is too warm. | Turn the temperature control knob to a | |
|
|
|
| higher number to allow the unit to run | |
|
|
|
| colder. Allow 24 hours before readjusting | |
|
|
|
| the temperature control. | |
|
|
| Blower inlet and/or outlet is restricted. | Keep blower area clear from commodities for | |
|
|
|
| proper operation. | |
|
|
| Condenser fan air flow is restricted. | Make certain the grille in front of the unit is | |
|
|
|
| free and open for proper air circulation. | |
|
|
|
| Check and clean the condenser coil by | |
|
|
|
| removing the grille in the front of the unit. | |
|
|
|
| Clean the condenser with a vacuum and | |
|
|
|
| brush attachment. | |
|
|
| Room and/or water temperature is too | Move the unit to an area where ambient | |
|
|
| warm. | temperature is below 90oF. The unit should | |
|
|
|
| not be placed next to a heat source such as | |
|
|
|
| an oven. Check for cold water connection. | |
| Small ice cubes | Water input may require adjustment | Due to differing water pressures, the ice |
| |
|
|
|
| maker water input may require adjusting. | |
| Noisy operation | Cabinet not level; | Adjust the leveling legs on the unit. |
| |
|
|
| weak floor structure. | The unit must be locate on a sound and | |
|
|
|
| sturdy floor for proper operation. | |
|
|
| Water line tubing vibration | Adjust the tubing as necessary to prevent | |
|
|
|
| unwanted vibrations. | |
| Ice cubes sticking together. | Ice consumption is low. | Use the ice in the bin frequently. Ice will |
| |
|
|
|
| stick together if left in insulated bin over | |
|
|
|
| long periods of time. | |
|
|
| Room temperature is too warm. | Move the unit to an area where temperature | |
|
|
|
| is below 90oF. | |
|
|
|
|
|
|
15