Latch Assembly | Vulcan-Hart VHX24E manual

VHX SERIES STEAMERS - REMOVAL AND REPLACEMENT OF PARTS

4.Remove the nuts and spacers from the handle screws and remove the handle from the door.

NOTE: When installing the spacers, the smaller diameter fits into the slot in the door and the latch lever must rest on top of the handle latch screw.

5.Reverse procedure to install.

NOTE: When installing screws at the top and bottom of door, apply thread sealant.

Latch Assembly

1.Open the door.

2.Remove screws from the top and bottom of the door.

3.Pull the inner door panel out from the door housing with the gasket plate and gasket still attached.

4.Remove the screws from the side edge of the door that secure the latch mechanism and remove the latch from the door.

NOTE: When installing, the latch lever must rest on top of the handle latch screw.

5.Reverse procedure to install.

NOTE: When installing screws at the top and bottom of door, apply thread sealant.

Page 15 of 48		F25154 (February 2004)

Image 15

Vulcan-Hart VHX24E service manual Latch Assembly

Contents

VHX24E Shown VHX Boiler Base Series High Efficiency Electric Steamer Table of Contents VHX Series Steamers INSTALLATION, Operation Cleaning Introduction GeneralModel Number of Pans PAN Depth PER Compartment Inches Boiler Pressure SpecificationsWater Conditioning Boiler Code Descriptions Special ToolsElectrical Standard Pressure Switch Control BOX Components Removal and Replacement of Parts Main Control BOX Components Left Side View Shown Water Level Gauge Assembly Heating Elements Heating Elements Heating Element Mounting Plate Right Side View Shown Boiler Assembly Descaler Cathodic Protector Handle Cooking Compartment DoorsRemoval Gasket Latch Assembly Boiler Service Procedures and Adjustments Water Level Probe Housing Blowdown Water Level Controls TestMain Water Level Control Auxiliary Low level Cut-Off Control Cycling Pressure Switch Adjustment Boiler Fill and Cold Water Condenser Solenoid Valves High Limit Pressure Switch Adjustment Cold Water Condenser Thermostat Adjustment Intake Shut-Off Valve Adjustment Steam Flow Heating Element TestCooking Compartment Door Latch Adjustment Door Sealing Adjustment Cold Water Condenser Reset Switch ManualElectrical Operation Component Function Compartment Pressure Switch Blowdown/DrainSteam Solenoid Valve Boiler Base Controls Component Locations Boiler Base Controls Cooking Compartment Controls Low Level Cut-Off & Differential Control Water Level Controls Auxiliary Low Level Cut-Off Relay Board Layout, Legend & Diagnostic Test Points Schematic Initial Fill and Preheat Sequence of Operation Boiler Blowdown/drain Water Refill After Initial Fill VHX Series Steamer Electrical Operation Schematics Cooking Compartment Controls Wiring Diagrams VHX Series Steamer Electrical Operation Heating Element Circuits Cooking Compartment Controls Troubleshooting Symptom Possible CausesBoiler Base Controls Symptom Possible Causes Symptom Possible Causes Cooking Compartment Controls VHX Series Steamer VHX Series Steamer Condensed Spare Parts List VHX24E, VHX24E5, MHB24EPart Number Description