Install flue collector | Weil-McLain 80 specs

• Installation • Start-Up • Maintenance • Parts

6 Install flue collector (continued)

Figure 11 Flue collector components by model (see Figure 10, page 11 for flue collector components not shown below)

Part No. 550-141-935/0602

13

Image 13

Weil-McLain 80 manual Install flue collector

Contents

Boiler Manual Contents Installation must comply with Before installing boilerBefore selecting boiler location Lay a foundation, if needed Provide combustion and ventilation air openings Using crane attach free end of cables to eye of crane For block assemblySet boiler in place For packaged boiler Assemble block Install back refractory blanketPrepare back section Place a block under pipe to hold section upright If using tankless heater TI sections Install intermediate sectionsPrepare remaining sections Prepare boiler and test Perform hydrostatic pressure test Install burner mounting plate on front section Complete block assemblyInstall cleanout plates Flue collector assembly Install flue collectorInstall collector hold-down bolts Prepare flue collector hood assembly Install flue collector After installing flue collector, ALL Boilers Before installing flue collectorRear flue boilers only Top flue boilers only Install flue collector Connect water boiler piping Install pipingGeneral water piping information Size secondary boiler pump GPM based on following formulas Piping for multiple boilers see Figure General steam piping information Connect steam boiler piping Connect steam boiler piping Condensate piping to boiler Condensate receiver capacity Multiple Steam Boiler Piping Gravity Condensate Return Before installing jacket Install jacketInstall support brackets and rails Install jacket front and rear panels Install jacket Install jacket top panels Install jacket side panelsInstall jacket trim Jacket side panel placement Models 380, 480, 580 Jacket side panel placement Models 780, 880 Jacket side panel placement Models 1080, 1180, Jacket top panel placement To pipe tankless heaters Pipe tankless heatersSize piping no smaller than heater inlet and outlet Install controls Install water boiler controls Install controls where shown in and Figure Install steam boiler controls Water level control locations see Table General venting information Construct metal breeching Connect breeching and venting systemsSelect type of venting system Wiring and fuel piping Install burnerMake final adjustments Check boiler for gas-tight seal Freeze protection when used Dimensions and ratings Dimensions and ratings Parts Parts Eye Irrigate immediately Breathing Fresh air Handling ceramic fiber and fiberglass materials Propane boilers propane gas odorant All Residential & Commercial Cast Iron Boilers