Poulan PP17538HP, 96041007302, 420408 manual Service And Adjustments, Front Wheel Toe-In/Camber

Page 24
FRONT WHEEL TOE-IN/CAMBER

SERVICE AND ADJUSTMENTS

FRONT WHEEL TOE-IN/CAMBER

Your new tractor front wheel toe-in and camber is set at the factory and is normal. The front wheel toe-in and camber are not adjustable. If damage has occurred to affect the factory set front wheel toe-in or camber, contact a qualified service center.

TO REMOVE WHEEL FOR REPAIRS (See Fig. 32)

•Block up axle securely.

•Remove axle cover, retaining ring and washers to allow wheel removal (rear wheel contains a square key - Do not lose).

•Repair tire and reassemble.

•On rear wheels only: align grooves in rear wheel hub and axle. Insert square key.

•Replace washers and snap retaining ring securely in axle groove.

•Replace axle cover.

NOTE: To seal tire punctures and prevent flat tires due to slow leaks, tire sealant may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion.

WASHERS

RETAINING

RING

AXLE COVER

SQUARE KEY (REAR

WHEEL ONLY)

FIG. 32

TO START ENGINE WITH A WEAK BATTERY (See Fig. 33)

WARNING: Lead-acid batteries gen- erate explosive gases. Keep sparks, flame and smoking materials away from batteries. Always wear eye protection when around batteries.

If your battery is too weak to start the engine, it should be recharged. (See "BATTERY" in the MAINTENANCE sec- tion of this manual).

If “jumper cables” are used for emergency starting, follow this procedure:

IMPORTANT: YOUR TRACTOR IS EQUIPPED WITH A 12 VOLT SYSTEM. THE OTHER VEHICLE MUST ALSO BE A 12 VOLT SYSTEM. DO NOT USE YOUR TRACTOR BATTERY TO START OTHER VEHICLES.

TO ATTACH JUMPER CABLES -

•Connect one end of the RED cable to the POSITIVE

(+)terminal of each battery(A-B), taking care not to short against tractor chassis.

•Connect one end of the BLACK cable to the NEGATIVE (-) terminal (C) of fully charged battery.

•Connect the other end of the BLACK cable (D) to good chassis ground, away from fuel tank and battery.

TO REMOVE CABLES, REVERSE ORDER -

•BLACK cable first from chassis and then from the fully charged battery.

•RED cable last from both batteries.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

WEAK OR DEAD

 

 

 

 

 

 

 

FULLY CHARGED

BATTERY

 

 

 

 

 

 

 

BATTERY

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

FIG. 33

24

Page 23 Page 25
Image 24
Page 23 Page 25
Contents MODEL IMPORTANT MANUALDO NOT THROW AWAY OPERATORS MANUALSAFETY RULES Safe Operation Practices for Ride-On MowersI. GENERAL OPERATION II. SLOPE OPERATIONV. SERVICE III. CHILDRENIV. TOWING TABLE OF CONTENTS PRODUCT SPECIFICATIONSCUSTOMER RESPONSIBILITIES UNASSEMBLED PARTS Steering WheelSeat 1 SeatASSEMBLY TOOLS REQUIRED FOR ASSEMBLYTOREMOVETRACTORFROMCARTON BEFORE REMOVING TRACTOR FROM SKIDINSTALL SEAT See Fig TO ADJUST SEAT See FigCHECKLIST PLEASE REVIEW THE FOLLOWING CHECKLISTCHECK TIRE PRESSURE CHECK DECK LEVELNESSOPERATION KNOW YOUR TRACTOR HG DEF K AC ML HOW TO USE YOUR TRACTOR TO SET PARKING BRAKE See FigSTOPPING TO USE THROTTLE CONTROL - D See FigTO ADJUST MOWER CUTTING HEIGHT See Fig TO ADJUST GAUGE WHEELS See FigTO OPERATE MOWER TO STOP MOWER BLADESBEFORE STARTING THE ENGINE TO OPERATE ON HILLSTO TRANSPORT See Figs. 5 and CHECK ENGINE OIL LEVELADD GASOLINE TO START ENGINE See FigPURGE TRANSMISSION MOWING TIPS MAINTENANCE GENERAL RECOMMENDATIONSMAINTENANCE SCHEDULETRACTOR BATTERYBRAKE OPERATION TIRESENGINE CLEAN AIR SCREENV-BELTS TRANSAXLE COOLINGCLEANING ENGINE COOLING SYSTEM See FigMUFFLER SPARK PLUGSSERVICE AND ADJUSTMENTS TO INSTALL MOWER See FigTO REMOVE MOWER See Fig G MF RG QG MF G Repeat on opposite side of tractorTO LEVEL MOWER TO REPLACE MOWER BLADE DRIVE BELT See Fig TO CHECK BRAKETO REPLACE MOTION DRIVE BELT See Fig MANDRELIDLER PULLEYPULLEYS MANDREL PULLEYTO START ENGINE WITH A WEAK BATTERY See Fig FRONT WHEEL TOE-IN/CAMBERTO REMOVE WHEEL FOR REPAIRS See Fig TRANSMISSION REPLACING BATTERY See FigTO REMOVE HOOD AND GRILL ASSEMBLY See Fig TO ADJUST THROTTLE CONTROL CABLESTORAGE OTHERFUEL SYSTEM ENGINE OILTROUBLESHOOTING POINTS TROUBLESHOOTING POINTS SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION ONLY RIDE UP AND DOWN HILL NOT ACROSS HILL 15 DEGREES MAXSERVICE NOTES SERVICE NOTES 10.29.09 SR
Top Page Image Contents