Subaru Robin Power Products RGX3510 Incandescent lamp, heater,etc. with a power factor of 1.O

Page 40

7.RANGE OF APPLICATIONS

Generally, the power ratingof an electrical appliance indicates the amountof work that can be done by it. The electric power required for operating an electrical appliance notis always equal to the output wattage of the appliance. The electrical appliances generally have a label showing their rated voltage, frequency, and power consumption (input wattage). The power consumption of an electrical appliance is the power necessary for using it. When using a generator for operating an electrical appliance,the power factor and starting wattage must be taken into consideration.

In order to determine the right size generator, it is necessary to add the total wattage of all appliances to be connected to the unit.

Refer to the followings to calculate the power consumptionof each appliance or equipmentby its type.

(1)Incandescent lamp, heater,etc. with a power factor of 1.O

Total power consumption must be equalto or less than therated output of the generator. Example: A rated 3OOOW generator can turn thirty lOOW incandescent lamps on.

(2)Fluorescent lamps, motor driven tools, light electrical appliances, etc. with a smallerpower factor

Select a generator with a rated output equivalent to 1.2 to 2 times of the power consumption of the load.

Gemrally the starting wattage of motor driven tools and light electrical appliances are 1.2 to 3 times lager than their running wattage.

Example: A rated 250W electric drill requires a 400W generator to start it.

NOTEI: If a power factor correction capacitor is not applied to the fluorescent lamp, themore power shall berequired to drive the lamps.

NOTE2: Nominal wattage of the fluorscent lamp generally indicates the output wattage of the

lamp. ~

Therefore,.if the fluorescent lamp has no special indication as to the power consumption, efficiency should be taken into account as explained in Item (5) on the following page.

(3)Mercury lamps with a smaller power factor

Loads for mercury lamps require 2to 3 times the indicated wattage during start-up. Example: A 4 O O W mercury lamp requires 800W to 1200W power source to be turned on.

A rated 30001%'generator can power two or three40014' mercury lamps.

(4)Initially loaded motor drivenappliancessuch as waterpumps,compressors,etc.

These appliances require large starting wattage which is3 to 5 times of running wattage. Example: A rated 9OOW compressor requires a 4500W generator to drive it.

NOTEI: Motor-driven appliances require the aforementioned generator output only at the starting. Once their motors are started, the appliances consume about 1.2 to 2 times their rated power consumption so that the excess power generated by the generator can be used for other electrical appliances.

NOTE2: Motor-driven appliances mentioned inItems (3) and (4) vary in their required motor starting power depending on the kind of motor and start-up load. If it is difficult to determine the optimum generator capacity, select a generator with a larger capacity.

- 37 -

Page 39 Page 41
Image 40
Page 39 Page 41
Contents Generator Contents No DCOutput Idle ControlOption for60 Hz only TlOlVNtl3llV Specifications3NIDN3 3NIEN3 Perfomance Curves RGXl810 Model RGX2410 RGX1810Output M a RGX2410 Model RGX3510RGX3510 3500W OutputMax 4MODELRGX5510 RGX5510RGX5510 5DC Output Option Features General Description 1EXTERNAL ViewRGX1810, RGX2410 50Hz, 60H~-llOV,12OVTYPE 2CONTROLPANELRGX1810, RGX2410 50Hz, 60H~-220V,240V Type RGXl810, RGX2410 50Hz,60Hz-11OV/220V, 120V/240V Type RGXl810,2410 50Hz-220V with SpecialreceptacleRGX1810,2410 AUSTRALIA, 50HZ-240V RGX3510 50Hz, 60Hz-1lOV,120V TypeRGX3510 50Hz, 60Hz-220VY 240VTYPE RGX3510 5OHZ, 60Hz-110V/22OVy120V/240V TypeRGX3510 50Hz-220V Withspecialreceptacle RGX3510 AUSTRALIA, 50HZ-240VRGX5510 50Hz, 60Hz-1lOV, 120V Type RGX5510 60H~-220V/240VTYPERGX5510 ~OHZ, 60H~-lIOV/220V,120V/240V Type RGX5510 50Hz-220V with Special ReceptacleRGX5510 AUSTRALIA, 50Hz-240V Location of Serial Number and Specification Number Constructionandfunction ConstructionFunction StatorCondenser RotorNO-FUSEBREAKER 4DC Fuse OptionRGX55 0 r \vJ Receptacle and AC Plug STD.SPEC1GENERATION Of NO-LOADVOLTAGE Generator OperationVoltage Fluctuations Under Load 3FULL Power Switch Dual voltage type RGX1810,2410,3510Dual voltagetype RGX5510 Page 4ELECTRONICIGNITIONSYSTEM Ignition Timing Plug Flywheel Cooling FANPower supply OIL Sensor 1DESCRIPTIONPrinciple of Sensingoillevel 3HOW Itoperates4BLOCK Diagram of the Circuit Judgement of oil levelDecision of oil shortage Automatic stopof enginePage Safety Precautions Do not place inflammable materialsnear the generatorIncandescent lamp, heater,etc. with a power factor of 1.O Mercury lamps with a smaller power factorAppliances without any indication as to power consumption Fluorescent lamp37/0.26 Measuring Procedures SpecificationsMeasuringinstruments 1 Dr. Robin Generator TesterAmmeters Instruments5oov AC Output Measuring DcoutputmeasuringMeasuring Insulation Resistance StatorControl Panel Voltmeter Checkingfunctionalmembers2AC Receptacles 4STATOR 3NO-FUSE Breaker5ROTOR Assembly Normal Capacityof Condenser 7DIODE RectifierCheckingtablefordigitalcircuittester OIL SensoroptionDisassembly and Assembly Preparation and Precautions10-2DISASSEMBLY Procedures Control box. See FIg Remove IIi Startor Stator Rotor Remo1.e rhe front cover 10-3ASSEMBLYPROCEDURES 10-3-1FRONTCOVER 120- 140 kgocrn 1‘ \ 8.7- 10.1 ft*lb Tighteningtorque11.3-13.2 N m Kg-cm \ Tt 8.7 10.8 ft4bFix Rear CoverH18 flan, nut Tightening torque Control BOXM8 nut 10-3-7FUEL Tank CHECKING, Disassembly and Reassembly of the Control BOX DisassemblyReassembly Checking of ThecontrolboxTroubleshooting 11-1NO AC Output Checking CondenserNormalcapacity of Condenser Checking StatorRemedy Checking RotorChecking Condenser Check condenser referring to -1-1 AC Voltge is TOO High or TOO LOW Checking Engine Speed11-2-4CHECKING Rotor Check the Appliance for Trouble Check if the Engine is OverheatedCheck the Insulation GeneratorCheck the Wiring Specification ResistanceCheck the DC Fuse 11 -4-4 Check the Diode Rectifier11-5-1ENGINE- Speedis not Increased When a Loadis Applied Idle Control Option for 60Hz onlyControl Unit Board Engine Speed is not Reduced When Load is OFF SolenoidWiring Diagram RGX1810, RGX2410 llOVGeneratorcontrolbox RGX1810, RGX2410 220VGenerator Control BOX RGXl810, RGX2410 11OV/22OV 120V/240VRGX3510 1lOV RGX3510 220V RGX3510 11OV/22OV 120V/240VRGX5510 11OV RGX5510 220VRGX5510 11OV/220V 120V/240V Generator ControlboxEngine Wiring Diagram . Recoil Stater Type Page 25 mm2 Symbols Part Name ISSUEEMD-GS1001

RGX3510 specifications

The Subaru Robin Power Products RGX3510 is a powerful and reliable generator designed to meet the demands of both residential and commercial users. This generator stands out in the market for its robust construction, advanced technology, and user-friendly features, making it an ideal choice for anyone in need of a dependable power source.

One of the main features of the RGX3510 is its impressive engine. Powered by a high-performance Subaru EH65 engine, this generator delivers exceptional output, capable of producing up to 3500 watts of continuous power. This level of output ensures that users have enough power to run essential appliances, tools, and equipment, whether for home use, outdoor events, or emergency situations.

The RGX3510 is equipped with advanced safety features that provide peace of mind during operation. Its built-in oil sensor automatically shuts down the engine if oil levels are low, preventing potential damage and ensuring longevity. Moreover, the generator includes a robust frame that is both lightweight and durable, designed to withstand harsh conditions while maintaining portability.

Another standout characteristic of the RGX3510 is its noise reduction technology. Subaru has integrated a series of sound-dampening features that significantly lower the operational noise level, making it one of the quieter models available. This aspect is particularly beneficial for residential use or in situations where noise pollution is a concern.

Fuel efficiency is another vital aspect of the RGX3510 that enhances its overall appeal. The generator is designed with an efficient combustion system, allowing it to run longer on a single tank of fuel. Users can enjoy extended operational time, reducing the frequency of refueling during extended power outages or work sessions.

The RGX3510 also includes a variety of output options, featuring multiple AC and DC outlets, ensuring compatibility with various devices and tools. The generator comes with an easy-to-read control panel, making it simple for users to monitor power output and manage their power needs efficiently.

In summary, the Subaru Robin Power Products RGX3510 generator combines power, efficiency, and ease of use. With its robust engine, advanced safety features, noise reduction technology, and user-friendly design, it stands as a reliable choice for anyone requiring a dependable generator for home or professional applications. This model exemplifies Subaru's commitment to engineering excellence, ensuring users receive quality performance and peace of mind with their power needs.
Top Page Image Contents