Generac 02010-0, 04164-0 owner manual Generator Identification, Model, Primepact 50LP

Page 6

Section 1 – General Information

PRIMEPACT 50 Recreational Vehicle Generator

1.1GENERATOR IDENTIFICATION

Please record the following information from the generator DATA DECAL or information decal.

1.	Model Number ____________________	2.	Serial Number __________________
3.	kW Rating__________________________	4.	Rated Voltage __________________

18

Model: 02010-0

PRIMEPACT 50

1.Generator Air Intake

2.Engine Start/Stop Switch

3.Fuse

4.Optional Remote Panel Receptacle (behind control panel)

5.Generator AC Output Leads (behind control panel)

6.Fuel Primer Switch

7.Circuit Breaker

8.Circuit Breaker

9.Starter Contactor

10.Fuel Inlet

11.Fuel Pump

12.Fuel Filter

13.Oil Filter

14.Oil Drain Cap

15.Oil Dipstick

16.Data Decal

17.Oil Fill

	Model: 04164-0
	PRIMEPACT 50LP
	1.	Generator Air Intake
	2.	Engine Start/Stop Switch
	3.	Fuse
	4.	Optional Remote Panel
		Receptacle (behind
		control panel)
	5.	Generator AC Output Leads
	17	(behind control panel)
	17	Fuel Primer Switch
	6.	Fuel Primer Switch
	7.	Circuit Breaker
	8.	Circuit Breaker
	9.	Starter Contactor
	10.	Fuel Solenoid
	11.	Demand Regulator
	12.	Oil Filter
	13.	Oil Drain Cap
	14.	Oil Dipstick
	15.	Data Decal
	16.	Oil Fill

4 Generac® Power Systems, Inc.

Image 6

Contents Power SYSTEMS, INC Authorized Service Dealer Location IntroductionPart II Installation Instructions Table of ContentsGeneral Hazards Electrical Hazards Primepact Generator IdentificationModel Primepact 50LPGenerator Applicability SafetySpecifications Generator AC Connection SystemEngine OIL Requirements Optional Propane Fuel SystemFuel Consumption EngineOptional Remote START/STOP Panel START/STOP SwitchGenerator Control Panel Fuel PrimerAutomatic Choke Gasoline only Before Starting the EngineStarting the Generator Stopping the Generator SUMMER/WINTER Heat Riser SystemLetting the Engine Stabilize Protection Systems LOW OIL Pressure SwitchHigh Temperature Switch Do not Overload the GeneratorAdditional Information Checking the Engine OIL Level Changing the Engine OIL AND/OR OIL FilterCleaning the Foam Precleaner Maintaining the Engine AIR CleanerClean AIR Intake Checking the Engine Spark PlugSpark Arrestor Muffler Cleaning the GeneratorBattery Maintenance WeeklyDrive Belt Exercising the GeneratorOUT of Service Procedure Removal from ServiceReturn to Service Part General Hazards Electrical Hazards Equipment Description Purpose and Scope ManualStandards Booklets Generator Engine Operating SpeedMajor Features and Dimensions Generator Support Location and SupportGenerator Location Suspended MountingCompartment Construction Generator CompartmentsGenerator Restraint Compartment SizeAcoustics Sound Insulating MaterialsTypical Noise Abatement 2.2.5 Compartment Floor Cutouts Cooling and Ventilating AIR Generator AirflowCooling AIR Inlet Openings Testing the Installation Gasoline Fuel SystemCompensating for Restrictions Generator Fuel Supply Line LP GAS Fuel SystemFuel Tank Rigid Fuel LinesVapor Withdrawal Primary RegulatorSome Important Considerations Gaseous CarburetionExcess Flow Valve Exhaust SystemFuel Supply Lines Leakage TestsMufflers and Spark Arrestors Exhaust System SafetyElectrical Connections Type of Exhaust SystemGenerator AC Connections WiringIsolating Different Power Sources ConduitPower Supply Cord Ground Fault Circuit InterruptersBattery Cables Optional AccessoriesRecommended Battery Battery Cable ConnectionsRemote Panel Models Remote Panel CablesBefore Initial START-UP Post Installation TestsTesting Under Load Initial StartInstallation Checklist Appendix 1 Notes Troubleshooting Guide Problem Cause CorrectionAppendix 3 Electrical Data Appendix 3 Electrical Data Appendix 4 Exploded Views and Parts Lists QTY. Description Appendix 4 Exploded Views and Parts Lists REGULATOR, GAS Fuel Appendix 4 Exploded Views and Parts Lists Lower Bearing Carrier Appendix 4 Exploded Views and Parts Lists Item Part no QTY. Description Appendix 4 Exploded Views and Parts Lists Piston Ring SET Appendix 4 Exploded Views and Parts Lists MANIFOLD, Intake Appendix 4 Exploded Views and Parts Lists BOLT, SHOULDER, M6 X 15 LG Your Warranty Rights and Obligations MANUFACTURER’S Emission Control System Warranty CoveragePURCHASER’S/OWNER’S Warranty Responsibilities Emission Control System Warranty Emission Related Parts Include the FollowingGenerac Power SYSTEMS, INC