Maxtor 94610H6, 93073H4, 96147H8, 91536H2, 92305H3 specifications Major HDA Components

Page 13

PRODUCT DESCRIPTION

Major HDA Components

Drive Mechanism

A brush-less DC direct drive motor rotates the spindle at 5,400 RPM (±0.1%). The dynamically balanced motor/spindle assembly ensures minimal mechanical run-out to the disks. A dynamic brake provides a fast stop to the spindle motor upon power removal. The speed tolerance includes motor performance and motor circuit tolerances.

Rotary Actuator

All DiamondMax 60 drives employ a rotary voice coil actuator which consists of a moving coil, an actuator arm assembly and stationary magnets. The actuator moves on a low-mass, low-friction center shaft. The low friction contributes to fast access times and low power consumption.

Read/Write Electronics

An integrated circuit mounted within the sealed head disk assembly (near the read/write heads) provides up to eight head selection (depending on the model), read pre-amplification and write drive circuitry.

Read/Write Heads and Media

Low mass, low force giant magneto-resistive read/write heads record data on 3.5-inch diameter disks. Maxtor uses a sputtered thin film medium on all disks for DiamondMax 60 drives.

Air Filtration System

All DiamondMax 60 drives are assembled in a Class 100 controlled environment. Over the life of the drive, a

0.1micron filter and breather filter located within the sealed head disk assembly (HDA) maintain a clean environment to the heads and disks. DiamondMax drives are designed to operate in a typical office environment with minimum environmental control.

Microprocessor

The microprocessor controls the following functions for the drive electronics:

Command execution

Cache management

Data correction and error recovery

Diagnostic execution

Data sequencing

Head positioning (including error recovery)

Host interface

Index detection

Spin speed control

Seeks

Servo

S.M.A.R.T.

2 – 4

Image 13
Contents DiamondMax U T I O N Before You BeginContents Product Specifications AT Interface Description Service and Support Figures Maxtor Corporation IntroductionManual Organization AbbreviationsConventions Product Description DiamondMax 60 Key FeaturesFunctional / Interface Product FeaturesModel CYL MAX LBA CapacityCache Management Major HDA Components Jumper Location / Configuration Subsystem ConfigurationCylinder Limitation Jumper Description Drive Configuration Product SpecificationsPerformance Specifications Models and CapacitiesParameter A N D a R D Metric Physical Dimensions maximumPower Mode Definitions Power RequirementsEPA Energy Star Compliance Environmental LimitsShock and Vibration Reliability SpecificationsParameter E R a T I N G EMC/EMI Safety Regulatory ComplianceHard Drive Handling Precautions Handling and InstallationElectro-Static Discharge ESD Multi-pack Shipping Container Unpacking and InspectionRepacking Physical InstallationHook up Before You BeginStart up Set upPIN Signal Interface ConnectorAT Interface Description Pin Description SummaryPin Description Table PIN Name Signal Name Signal DescriptionPIO Timing Timing Parameters ModeDMA Timing Timing Parameters all times in nanoseconds Ultra DMA TimingSustained Ultra DMA Data In Burst Device Terminating an Ultra DMA Data In Burst Initiating an Ultra DMA Data Out Burst Device Pausing an Ultra DMA Data Out Burst Device Terminating an Ultra DMA Data Out Burst Task File Registers Host Software InterfacePort Read Write N T E N T S LBA Bits Command Register R a M E T E R S U S E D SummaryControl Diagnostic Registers Reset and Interrupt Handling Interface Commands Read Commands Read DMA Write Commands Write Multiple Value Description Mode Set/Check CommandsEV E L Value M M a N D Timer Value TIME-OUT Period Power Mode CommandsSleep Mode Content Description Initialization Commands15 -3 = reserved R D Content Description Initialize Drive Parameters Error Code Description Seek, Format and Diagnostic CommandsKey Register A.R.T. Command SetService Policy Service and SupportNo Quibble Service SupportFrom Dial Block GlossaryCorrectableerror Fetch Landingzoneorlzone Physicalsector Softerror