Sub-Zero BBQ36C, BBQ48BI, BBQ362C, BBQ48C, BBQ362BI manual E a N I N G T H E B U R N E R S

Page 16

W O L F GAS BBQ GRILL U S E & C A R E

CLEANING A N D M A I N T E N A N C E

C L E A N I N G T H E B U R N E R S

Spiders or small insects may spin webs or build nests inside the burners, especially in late summer and fall when spiders are most active. These nests can obstruct gas flow and cause a fire in and around the valve. Such a fire can cause operator injury and serious damage to your BBQ grill.

To help prevent a blockage and ensure full heat output, clean and inspect the burners once or twice a month.

Spider webs or wasps’ nests inside the burner may cause a fire at the burner valve.

To access grill burners: Remove the grill grates and stainless steel radiants. The radiants are supported on each end by a pin located just above each grill burner. Lift the burner tubes up in the back and off the orifice at the front.

To access side burners: After removing the burner grates on the open burner section, lift the porcelain-coated cast iron burners up at the rear and off the orifice at the front.

Wash burners in warm soapy water, rinse and dry.

Using a flashlight, look inside the end of the burners for webs or mud nests.

Using the special venturi cleaner brush provided, push the brush through the full length of each burner several times. Refer to the illustration below.

For burner ports, clean the gas holes with a paper clip if blocked.

To replace the burners, slide the bell-shaped or cylindrical end over the valve orifices.

Test-light to see if the burner is operating properly.

Cleaning the grill tank bottom: Before you put back the grill burners, check to see if you have an accumulation of carbon and burned food on the bottom of the grill tank. If so, use a spatula or scraper and push the carbon to the front and into the drip tray to collect and dispose of.

Grill Grate

Radiant

Burner

BBQ grill components

Insert Venturi Brush

to Clean

Venturi

Cleaning the burner

16

Page 15 Page 17
Image 16
Page 15 Page 17
Contents USE & Care Information N T E N T S Thank YOU T R O D U C I N G Wolf GAS BBQ GrillsN TA C T F O R M AT I O N F E T Y I N S T R U C T I O N S a N D P R E C a U T I O N S AT not to do L F GAS BBQ Grill F E AT U R E S GAS BBQ Grill F E AT U R E SL F R R a N T Y BBQ grill components Radiant positioningFlame a D J U S T M E N T Before L I G H T I N G L F GAS BBQ Grill U S E & C a R EBefore Grilling T H E F I R S T T I M E G H T I N G T H E O P E N B U R N E R S E N BurnersFlame H E I G H T Manual lighting E PA R I N G F O O D O K I N G P O U LT RY I L L I N G Methods Heat S E T T I N G STips F O R S U C C E S S F U L G R I L L I N G Battery installation T E R I O R C L E a N I N G E a N I N G I N T E R N a L PA RT SE a N I N G T H E B U R N E R S Beef L F BBQ Grilling G U I D EPork Lamb Poultry Vegetables FruitL F Troubleshooting G U I D E Troubleshooting G U I D EF O R E C a L L I N G F O R S E RV I C E L F Service I N F O R M AT I O NRO D U C T R E G I S T R AT I O N Full TWO Year Warranty 7 5 7 2 0 0
Top Page Image Contents